Production of ceramics from coal fly ash

Dense ceramics are produced from fly ash from REK Bitola, Republic of Macedonia. Four types of fly ash from electro filters and one from the collected zone with particles < 0.063 mm were the subject of this research. Consolidation was achieved by pressing (P= 133 MPa) and sintering (950, 1000, 1050 and 11000C and heating rates of 3 and 100/min). Densification was realized by liquid phase sintering and solid state reaction where diopside [Ca(Mg,Al)(Si,Al)2O6] was formed. Ceramics with optimal properties (porosity 2.96±0.5%, bending strength - 47.01±2 MPa, compressive strength - 170 ±5 MPa) was produced at 1100ºC using the heating rate of 10ºC/min

Inspiratory muscle training reduces blood lactate concentration during volitional hyperpnoea

Although reduced blood lactate concentrations ([lac−]B) have been observed during whole-body exercise following inspiratory muscle training (IMT), it remains unknown whether the inspiratory muscles are the source of at least part of this reduction. To investigate this, we tested the hypothesis that IMT would attenuate the increase in [lac−]B caused by mimicking, at rest, the breathing pattern observed during high-intensity exercise. Twenty-two physically active males were matched for 85% maximal exercise minute ventilation (V˙Emax) and divided equally into an IMT or a control group. Prior to and following a 6 week intervention, participants performed 10 min of volitional hyperpnoea at the breathing pattern commensurate with 85% V˙Emax

Physical Activity Characteristics across GOLD Quadrants Depend on the Questionnaire Used

BACKGROUND:The GOLD multidimensional classification of COPD severity combines the exacerbation risk with the symptom experience, for which 3 different questionnaires are permitted. This study investigated differences in physical activity (PA) in the different GOLD quadrants and patient's distribution in relation to the questionnaire used. METHODS:136 COPD patients (58±21% FEV1 predicted, 34F/102M) completed COPD assessment test (CAT), clinical COPD questionnaire (CCQ) and modified Medical Research Council (mMRC) questionnaire. Exacerbation history, spirometry and 6MWD were collected. PA was objectively measured for 2 periods of 1 week, 6 months apart, in 5 European centres; to minimise seasonal and clinical variation the average of these two periods was used for analysis. RESULTS:GOLD quadrants C+D had reduced PA compared with A+B (3824 [2976] vs. 5508 [4671] steps.d-1, p<0.0001). The choice of questionnaire yielded different patient distributions (agreement mMRC-CAT κ = 0.57; CCQ-mMRC κ = 0.71; CCQ-CAT κ = 0.72) with different clinical characteristics. PA was notably lower in patients with an mMRC score ≥2 (3430 [2537] vs. 5443 [3776] steps.d-1, p <0.001) in both the low and high risk quadrants. CONCLUSIONS:Using different questionnaires changes the patient distribution and results in different clinical characteristics. Therefore, standardization of the questionnaire used for classification is critical to allow comparison of different studies using this as an entry criterion. CLINICAL TRIAL REGISTRATION:ClinicalTrials.gov NCT01388218

Predictive significance of the six-minute walk distance for long-term survival in chronic hypercapnic respiratory failure

Background: The 6-min walk distance ( 6-MWD) is a global marker of functional capacity and prognosis in chronic obstructive pulmonary disease ( COPD), but less explored in other chronic respiratory diseases. Objective: To study the role of 6-MWD in chronic hypercapnic respiratory failure ( CHRF). Methods: In 424 stable patients with CHRF and non-invasive ventilation ( NIV) comprising COPD ( n = 197), restrictive diseases ( RD; n = 112) and obesity-hypoventilation- syndrome ( OHS; n = 115), the prognostic value of 6-MWD for long- term survival was assessed in relation to that of body mass index (BMI), lung function, respiratory muscle function and laboratory parameters. Results: 6-MWD was reduced in patients with COPD ( median 280 m; quartiles 204/350 m) and RD ( 290 m; 204/362 m) compared to OHS ( 360 m; 275/440 m; p <0.001 each). Overall mortality during 24.9 (13.1/40.5) months was 22.9%. In the 424 patients with CHRF, 6-MWD independently predicted mortality in addition to BMI, leukocytes and forced expiratory volume in 1 s ( p <0.05 each). In COPD, 6-MWD was strongly associated with mortality using the median {[} p <0.001, hazard ratio ( HR) = 3.75, 95% confidence interval (CI): 2.24-6.38] or quartiles as cutoff levels. In contrast, 6-MWD was only significantly associated with impaired survival in RD patients when it was reduced to 204 m or less (1st quartile; p = 0.003, HR = 3.31, 95% CI: 1.73-14.10), while in OHS 6-MWD had not any prognostic value. Conclusions: In patients with CHRF and NIV, 6-MWD was predictive for long- term survival particularly in COPD. In RD only severely reduced 6-MWD predicted mortality, while in OHS 6-MWD was relatively high and had no prognostic value. These results support a disease-specific use of 6-MWD in the routine assessment of patients with CHRF. Copyright (C) 2007 S. Karger AG, Basel

Respiratorni simptomi u radnica na preradi riba na obali Jadrana u Hrvatskoj

This article describes respiratory symptoms and lung function in 98 fish processing female workers employed in a fish processing plant located on the Croatian Adriatic coast and 95 matching controls. The study included chronic and acute respiratory symptoms which developed during the shifts. Lung function measurements included forced vital capacity (FVC), one-second forced expiratory volume (FEV1) and maximal expiratory rates at 50 % and the last 25 % (FEF50, FEF25). Chronic respiratory symptoms were significantly dominant in fish processing workers compared to controls. The most common chronic symptoms were hoarseness (57.1 %), nasal catarrh (51.0 %), chronic cough (42.9 %), chronic phlegm (34.7 %), and frequent chest cold (35.7 %). Exposed smokers and nonsmokers had a similar prevalence of chronic respiratory symptoms. Acute symptoms over the work shift were high, with headache in lead (smokers: 62.5 %; nonsmokers: 56.1 %). Most of the ventilatory capacity parameters were significantly lower than predicted, FEF25 in particular, indicating obstructive changes predominantly in the smaller airways. These findings suggest that fish processing workers are prone to developing acute and chronic respiratory symptoms as well as to lung function changes. This calls for medical and technical preventive measures to be introduced in the work environment of the fi sh processing plant.Cilj je ovoga istraživanja bio ispitati respiratorne simptome i plućnu funkciju radnica zaposlenih na preradi riba u industriji na obali Jadranskog mora u Hrvatskoj. U istraživanje je uključeno 98 radnica zaposlenih na preradi riba i 95 žena neizložene kontrolne skupine. Ispitivani su kronični i akutni respiratorni simptomi koji se razvijaju tijekom radne smjene. Mjerena je plućna funkcija registriranjem forsiranoga vitalnog kapaciteta (FVC), forsiranoga ekspiracijskog volumena u prvoj sekundi (FEV1) te maksimalnoga ekspiracijskog protoka pri 50 % i zadnjih 25 % forsiranoga vitalnog kapaciteta (FEF50, FEF25) na krivulji maksimalni ekspiracijski protok-volumen (MEPV). Učestalost većine kroničnih respiracijskih simptoma bila je značajno viša u eksponiranih u usporedbi s kontrolnom skupinom. U eksponiranih radnica utvrđena je i visoka prevalencija akutnih simptoma koji se razvijaju tijekom radne smjene, posebno za promuklost (57,1 %) i katar nosa (51 %), potom slijedi kronični kašalj (42,9 %), kronični iskašljaj (34,7 %), upale sinusa (32 %) i česte prehlade (35,7 %). S obzirom na naviku pušenja pušači i nepušači imali su sličnu prevalenciju kroničnih respiratornih simptoma. Izložene radnice imale su visoku prevalenciju akutnih simptoma tijekom radne smjene i to naročito za glavobolju (pušači 62,5 %; nepušači 56,1 %). Ventilacijska funkcija pluća bila je značajno smanjena u usporedbi s predviđenim normalnim vrijednostima posebice za FEF25 % upućujući na opstruktivne promjene pretežno u manjim dišnim putovima. Naši podaci upućuju na opasnost razvoja kroničnih i akutnih respiracijskih simptoma i promjena plućne funkcije u radnika koji rade u industriji na preradi riba. Medicinske i tehničke preventivne mjere u radnom okolišu treba preporučiti u industriji prerade riba

Supine posture changes lung volumes and increases ventilation heterogeneity in cystic fibrosis

INTRODUCTION: Lung Clearance Index (LCI) is recognised as an early marker of cystic fibrosis (CF) lung disease. The effect of posture on LCI however is important when considering longitudinal measurements from infancy and when comparing LCI to imaging studies. METHODS: 35 children with CF and 28 healthy controls (HC) were assessed. Multiple breath washout (MBW) was performed both sitting and supine in triplicate and analysed for LCI, Scond, Sacin, and lung volumes. These values were also corrected for the Fowler dead-space to create 'alveolar' indices. RESULTS: From sitting to supine there was a significant increase in LCI and a significant decrease in FRC for both CF and HC (p<0.01). LCI, when adjusted to estimate 'alveolar' LCI (LCIalv), increased the magnitude of change with posture for both LCIalv and FRCalv in both groups, with a greater effect of change in lung volume in HC compared with children with CF. The % change in LCIalv for all subjects correlated significantly with lung volume % changes, most notably tidal volume/functional residual capacity (Vtalv/FRCalv (r = 0.54,p<0.001)). CONCLUSION: There is a significant increase in LCI from sitting to supine, which we believe to be in part due to changes in lung volume and also increasing ventilation heterogeneity related to posture. This may have implications in longitudinal measurements from infancy to older childhood and for studies comparing supine imaging methods to LCI

Effects of a partially supervised conditioning programme in cystic fibrosis: an international multi-centre randomised controlled trial (ACTIVATE-CF): study protocol

Physical activity (PA) and exercise have become an accepted and valued component of cystic fibrosis (CF) care. Regular PA and exercise can positively impact pulmonary function, improve physical fitness, and enhance health-related quality of life (HRQoL). However, motivating people to be more active is challenging. Supervised exercise programs are expensive and labour intensive, and adherence falls off significantly once supervision ends. Unsupervised or partially supervised programs are less costly and more flexible, but compliance can be more problematic. The primary objective of this study is to evaluate the effects of a partially supervised exercise intervention along with regular motivation on forced expiratory volume in 1 s (FEV1) at 6 months in a large international group of CF patients. Secondary endpoints include patient reported HRQoL, as well as levels of anxiety and depression, and control of blood sugar.; It is planned that a total of 292 patients with CF 12 years and older with a FEV1 ≥ 35% predicted shall be randomised. Following baseline assessments (2 visits) patients are randomised into an intervention and a control group. Thereafter, they will be seen every 3 months for assessments in their centre for one year (4 follow-up visits). Along with individual counselling to increase vigorous PA by at least 3 h per week on each clinic visit, the intervention group documents daily PA and inactivity time and receives a step counter to record their progress within a web-based diary. They also receive monthly phone calls from the study staff during the first 6 months of the study. After 6 months, they continue with the step counter and web-based programme for a further 6 months. The control group receives standard care and keeps their PA level constant during the study period. Thereafter, they receive the intervention as well.; This is the first large, international multi-centre study to investigate the effects of a PA intervention in CF with motivational feedback on several health outcomes using modern technology. Should this relatively simple programme prove successful, it will be made available on a wider scale internationally.; ClinicalTrials.gov Identifier: NCT01744561 ; Registration date: December 6, 2012

Primary Ciliary Dyskinesia Due to Microtubular Defects is Associated with Worse Lung Clearance Index

PURPOSE: Primary ciliary dyskinesia (PCD) is characterised by repeated upper and lower respiratory tract infections, neutrophilic airway inflammation and obstructive airway disease. Different ultrastructural ciliary defects may affect lung function decline to different degrees. Lung clearance index (LCI) is a marker of ventilation inhomogeneity that is raised in some but not all patients with PCD. We hypothesised that PCD patients with microtubular defects would have worse (higher) LCI than other PCD patients. METHODS: Spirometry and LCI were measured in 69 stable patients with PCD. Age at testing, age at diagnosis, ethnicity, ciliary ultrastructure, genetic screening result and any growth of Pseudomonas aeruginosa was recorded. RESULTS: Lung clearance index was more abnormal in PCD patients with microtubular defects (median 10.24) than those with dynein arm defects (median 8.3, p = 0.004) or normal ultrastructure (median 7.63, p = 0.0004). Age is correlated with LCI, with older patients having worse LCI values (p = 0.03, r = 0.3). CONCLUSION: This study shows that cilia microtubular defects are associated with worse LCI in PCD than dynein arm defects or normal ultrastructure. The patient's age at testing is also associated with a higher LCI. Patients at greater risk of obstructive lung disease should be considered for more aggressive management. Differences between patient groups may potentially open avenues for novel treatments

Survival in severe alpha-1-antitrypsin deficiency (PiZZ)

<p>Abstract</p> <p>Background</p> <p>Previous studies of the natural history of alpha-1-antitrypsin (AAT) deficiency are mostly based on highly selected patients. The aim of this study was to analyse the mortality of PiZZ individuals.</p> <p>Methods</p> <p>Data from 1339 adult PiZZ individuals from the Swedish National AAT Deficiency Registry, followed from 1991 to 2008, were analysed. Forty-three percent of these individuals were identified by respiratory symptoms (respiratory cases), 32% by liver diseases and other diseases (non-respiratory cases) and 25% by screening (screened cases). Smoking status was divided into two groups: smokers 737 (55%) and 602 (45%) never-smokers.</p> <p>Results</p> <p>During the follow-up 315 individuals (24%) died. The standardised mortality rate (SMR) for respiratory cases was 4.70 (95% Confidence Interval (CI) 4.10-5.40), 3.0 (95%CI 2.35-3.70) for the non-respiratory cases and 2.30 (95% CI 1.46-3.46) for the screened cases. The smokers had a higher mortality risk than never-smokers, with a SMR of 4.80 (95%CI 4.20-5.50) for the smokers and 2.80(95%CI 2.30-3.40) for the never-smokers. The Rate Ratio (RR) was 1.70 (95% CI 1.35-2.20). Also among the screened cases, the mortality risk for the smokers was significantly higher than in the general Swedish population (SMR 3.40 (95% CI 1.98-5.40).</p> <p>Conclusion</p> <p>Smokers with severe AAT deficiency, irrespective of mode of identification, have a significantly higher mortality risk than the general Swedish population.</p