Effect of spraying parameters on the microstructural and corrosion properties of HVAF-sprayed Fe-Cr-Ni-B-C coatings

Thermally sprayed Fe-based coatings have been extensively studied as future solution in order to replace more expensive, harmful and environmentally dangerous Ni- and WC-based coatings for several industrial applications where high corrosion and wear resistance are required. The aim of the present study is to investigate the effect of spraying parameters on the microstructure and the corrosion resistance of Fe-based coatings manufactured with the High Velocity Air Fuel (HVAF) thermal spray process. Six sets of thermal spraying parameters have been chosen and their effect on the overall quality of coatings was investigated. All HVAF coatings showed comparably dense microstructure with near-zero oxidation, proving the high quality of the deposition process. However, higher anti-corrosion and mechanical properties were achieved by increasing the spraying air pressure and decreasing the particle feeding rate without altering the thickness and the overall deposition rate. Powder feeding rate was reported to have a remarkable effect on microstructure and corrosion properties. Coatings with beneficial compressive residual stresses were successfully obtained by increasing air pressure during spraying which resulted in improved microstructural and corrosion properties

Properties of arc-sprayed coatings from Fe-based cored wires for high-temperature applications

Equipment of a thermal power plant is subjected to high temperature oxidation and wear. This raises operating costs through frequent repair of worn parts and high metal consumption. The paper proposes a possible solution to this problem through arc spraying of protective coatings. Cored wires of the Fe-Cr-C basic alloying system are used as a feedstock. Additional alloying by Al, B, Si, Ti and Y allows one to create wear- and heat-resistant coatings, which are an attractive substitute of more expensive Co- and Ni-based materials. © 2017 Author(s)

Over 2000-Fold Increased Production of the Leaderless Bacteriocin Garvicin KS by Increasing Gene Dose and Optimization of Culture Conditions

The leaderless bacteriocin Garvicin KS (GarKS) is a potent antimicrobial, being active against a wide range of important pathogens. GarKS production by the native producer Lactococcus garvieae KS1546 is, however, relatively low (80 BU/ml) under standard laboratory growth conditions (batch culture in GM17 at 30°C). To improve the production, we systematically evaluated the impact of different media and media components on bacteriocin production. Based on the outcomes, a new medium formulation was made that increased GarKS production about 60-fold compared to that achieved in GM17. The new medium was composed of pasteurized milk and tryptone (PM-T). GarKS production was increased further 4-fold (i.e., to 20,000 BU/ml) by increasing the gene dose of the bacteriocin gene cluster (gak) in the native producer. Finally, a combination of the newly composed medium (PM-T), an increased gene dose and cultivation at a constant pH 6 and a 50–60% dissolved oxygen level in growth medium, gave rise to a GarKS production of 164,000 BU/ml. This high production, which is about 2000-fold higher compared to that initially achieved in GM17, corresponds to a GarKS production of 1.2 g/L. To our knowledge, this is one of the highest bacteriocin production reported hitherto

Steroidogenic factor 1 (NR5A1) induces multiple transcriptional changes during differentiation of human gonadal-like cells

Peer reviewe

Human pluripotent stem cell-derived cells endogenously expressing follicle-stimulating hormone receptors : modeling the function of an inactivating receptor mutation

Follicle-stimulating hormone (FSH) is crucial in the development and regulation of reproductive functions. The actions of human FSH and its receptor (FSHR) and mutations therein have mainly been studied using in vivo models, primary cells, cancer cells and cell lines ectopically expressing the FSHR. To allow studies of endogenous FSHR function in vitro, we differentiated FSHR-expressing cells from human pluripotent stem cells. FSH stimulation of the wild-type (WT), but not the inactivating Finnish founder mutant (A189V) receptor, activated the canonical cyclic adenosine monophosphate (cAMP)-dependent signaling pathway and downstream mediators. To investigate protein-protein interaction partners of FSHR at resting state and upon FSH stimulation, we expressed FSHR in HEK293 cells followed by affinity purification mass spectrometry analyses. We found 19 specific high-confidence interacting proteins for WT FSHR and 14 for A189V FSHR, several of which have been linked to infertility. Interestingly, while only WT FSHR interacted with FSH, insulin-like growth factor 1 receptor (IGF1R), for example, interacted with both WT and A189V FSHR upon FSH stimulation. In conclusion, our protocol allows detailed studies of FSH action and disease modeling in human cells endogenously expressing FSHR.Peer reviewe

Human pluripotent stem cell-derived cells endogenously expressing follicle-stimulating hormone receptors : modeling the function of an inactivating receptor mutation

Follicle-stimulating hormone (FSH) is crucial in the development and regulation of reproductive functions. The actions of human FSH and its receptor (FSHR) and mutations therein have mainly been studied using in vivo models, primary cells, cancer cells and cell lines ectopically expressing the FSHR. To allow studies of endogenous FSHR function in vitro, we differentiated FSHR-expressing cells from human pluripotent stem cells. FSH stimulation of the wild-type (WT), but not the inactivating Finnish founder mutant (A189V) receptor, activated the canonical cyclic adenosine monophosphate (cAMP)-dependent signaling pathway and downstream mediators. To investigate protein-protein interaction partners of FSHR at resting state and upon FSH stimulation, we expressed FSHR in HEK293 cells followed by affinity purification mass spectrometry analyses. We found 19 specific high-confidence interacting proteins for WT FSHR and 14 for A189V FSHR, several of which have been linked to infertility. Interestingly, while only WT FSHR interacted with FSH, insulin-like growth factor 1 receptor (IGF1R), for example, interacted with both WT and A189V FSHR upon FSH stimulation. In conclusion, our protocol allows detailed studies of FSH action and disease modeling in human cells endogenously expressing FSHR.Peer reviewe

Complement in Human Pre-implantation Embryos: Attack and Defense

It is essential for early human life that mucosal immunological responses to developing embryos are tightly regulated. An imbalance of the complement system is a common feature of pregnancy complications. We hereby present the first full analysis of the expression and deposition of complement molecules in human pre-implantation embryos. Thus, far, immunological imbalance has been considered in stages of pregnancy following implantation. We here show that complement activation against developing human embryos takes place already at the pre-implantation stage. Using confocal microscopy, we observed deposition of activation products on healthy developing embryos, which highlights the need for strict complement regulation. We show that embryos express complement membrane inhibitors and bind soluble regulators. These findings show that mucosal complement targets human embryos, and indicate potential adverse pregnancy outcomes, if regulation of activation fails. In addition, single-cell RNA sequencing revealed cellular expression of complement activators. This shows that the embryonic cells themselves have the capacity to express and activate C3 and C5. The specific local embryonic expression of complement components, regulators, and deposition of activation products on the surface of embryos suggests that complement has immunoregulatory functions and furthermore may impact cellular homeostasis and differentiation at the earliest stages of life.Peer reviewe

S-100B Concentrations Predict Disease-Free Survival in Stage III Melanoma Patients

Elevation of the tumor marker S-100B in melanoma patients is a highly specific indicator of recurrence. The role of S-100B in disease-free survival (DFS) was evaluated in stage III melanoma patients (staged with fluorodeoxyglucose positron emission tomography [FDG-PET] and computed tomography [CT]) with palpable lymph node metastases who underwent therapeutic lymph node dissection. S-100B and LDH were measured on the day before surgery (d = -1) and on days 1, 2, and 7 postoperatively. Multivariate logistic regression was used to study factors associated with preoperative elevation of S-100B. Univariate (log-rank test) and multivariate (Cox regression) survival analyses were performed to identify factors associated with DFS. Between 2004 and 2008, 56 patients (median age 57, range 24-93) years, 27 males (48%) and 29 females (52%) entered the study. Preoperative S-100B elevation was found in 27 patients (48%) and elevated LDH in 20 patients (36%). No association was found between these two markers at any time. Multivariate analysis showed that elevated S-100B preoperatively (hazard ratio [HR] 2.7, P = .03) was associated with DFS. S-100B elevation was associated with increased tumor size (odds ratio [OR] 3.40; P = .03). Elevated S-100B preoperatively in patients with optimally staged clinical stage III melanoma is associated with decreased disease-free survival. S100-B could be used as a prognostic marker in the stratification of new adjuvant trials to select stage III melanoma patients for adjuvant systematic treatment

Steroidogenic factor 1 (NR5A1) induces multiple transcriptional changes during differentiation of human gonadal-like cells

Nuclear receptor subfamily 5 group A member 1 (NR5A1) encodes steroidogenic factor 1 (SF1), a key regulatory factor that determines gonadal development and coordinates endocrine functions. Here, we have established a stem cell-based model of human gonadal development and applied it to evaluate the effects of NR5A1 during the transition from bipotential gonad to testicular cells. We combined directed differentiation of human induced pluripotent stem cells (46,XY) with activation of endogenous NR5A1 expression by conditionally-inducible CRISPR activation. The resulting male gonadal-like cells expressed several Sertoli cell transcripts, secreted anti-Müllerian hormone and responded to follicle-stimulating hormone by producing sex steroid intermediates. These characteristics were not induced without NR5A1 activation. A total of 2691 differentially expressed genetic elements, including both coding and non-coding RNAs, were detected immediately following activation of NR5A1 expression. Of those, we identified novel gonad-related putative NR5A1 targets, such as SCARA5, which we validated also by immunocytochemistry. In addition, NR5A1 activation was associated with dynamic expression of multiple gonad- and infertility-related differentially expressed genes. In conclusion, by combining targeted differentiation and endogenous activation of NR5A1 we have for the first time, been able to examine in detail the effects of NR5A1 in early human gonadal cells. The model and results obtained provide a useful resource for future investigations exploring the causative reasons for gonadal dysgenesis and infertility in humans.</p