10 research outputs found
N-nitrosamine rejection by nanofiltration and reverse osmosis membranes: The importance of membrane characteristics
The influence of membrane characteristics on the rejection of eight N-nitrosamines was investigated using one nanofiltration (NF), one seawater reverse osmosis (SWRO) and six low pressure reverse osmosis (LPRO) membranes. The rejection of the two lowest molecular weight N-nitrosamines, namely N-nitrosodimethylamine (NDMA) and N-nitrosomethylethylamine (NMEA), varied in the range from 8-82% to 23-94%, respectively. In general, the rejection of NDMA and NMEA increased with decreasing membrane permeability. The impact of membrane characteristics became less important for higher molecular weight N-nitrosamines. Among the four LPRO membranes (i.e. ESPA2, LFC3, TFC-HR and 70LW) that are commonly used for water reclamation applications, similar rejections were obtained for NDMA (37-52%) and NMEA (69-82%). In addition, rejection values of NDMA and NMEA among two LPRO membranes (i.e. ESPA2 and 70LW) were almost identical when compared under variable permeate flux and feed temperature conditions. However, it is noteworthy that the ESPABmembrane could achieve very high rejection of NDMA (as high as 71%) despite having a similar permeability to the LPRO membranes. Results reported here suggest that membrane characteristics associated with permeability such as the pore size and thickness of the active skin layer can be a key factor determining N-nitrosamine rejection
Seasonal variations in fate and removal of trace organic chemical contaminants while operating a full-scale membrane bioreactor
N-nitrosamine removal by reverse osmosis for indirect potable water reuse – A critical review based on observations from laboratory, pilot and full-scale studies
N-nitrosodimethylamine (NDMA) and several other N-nitrosamines have been identified as probable human carcinogens. Here, we review key aspects related to the occurrence and removal of N-nitrosamines by reverse osmosis (RO) membranes in the context of indirect potable water reuse. A comprehensive analysis of the existing data reveals significant variations in the rejection of NDMA by RO membranes reported in the literature, ranging from negligible up to 86%. This review article provides some insight into the reasons for such variations by examining the available data on the effects of operating conditions on NDMA rejection. Amongst several operating parameters investigated so far in the literature, feed temperature, membrane permeate flux, feed solution pH and ionic strength were found to have considerable impact on NDMA rejection by RO membranes. In particular, it has been recently shown that seasonal changes in feed temperature (e.g. from 20 to 30 C) can result in a significant decrease in NDMA rejection (from 49% to 25%). However, the combined effects of all operating parameters identified in the literature to date can only account for some of the variations in NDMA rejection that have been observed in full-scale RO plants. The impacts of membrane fouling and particularly chemical cleaning on the rejection of N-nitrosamines have not been fully investigated. Finally, this review article presents a roadmap for further research required to optimise the rejection of NDMA and other N-nitrosamines by RO membranes
Modelling the rejection of N-nitrosamines by a spiral-wound reverse osmosis system: mathematical model development and validation
A mathematical model was developed based on the irreversible thermodynamic principle and hydro- dynamic calculation to predict the rejection of N-nitrosamines by spiral-wound reverse osmosis (RO) membrane systems. The developed model is able to accurately describe the rejection of N-nitrosamines under a range of permeate flux and system recovery conditions. The modelled N-nitrosamine rejections were in good agreement with values obtained experimentally using a pilot-scale RO filtration system. Simulation from the model revealed that an increase in permeate flux from10 to 30L/m2h led to an increase in the rejection of low molecular weight N-nitrosamines such as N-nitrosodimethylamine (NDMA) (from31% to 54%), which was validated by experimental results. The modelling results also revealed that an increase in recovery caused a decrease in the rejection of these N-nitrosamines, which is consistent with the experimental results. Further modelling investigations suggested that NDMA rejection by a spiral-wound system can drop from 49% to 35% when the overall recovery increased from 10% to 50%. The model developed from this study can be a useful tool for water utilities and regulators fo rsystem design and evaluating the removal of N-nitrosamine by RO membranes
Effects of membrane fouling on N-nitrosamine rejection by nanofiltration and reverse osmosis membranes
The impact of fouling on N-nitrosamine rejection by nanofiltration (NF) and reverse osmosis (RO) membranes was investigated in this study. Membrane fouling was simulated using tertiary treated effluent and several model fouling solutions (that contained sodium alginate, bovine serum albumin, humic acid or colloidal silica) to elucidate the changes in rejection behaviour of N-nitrosamines. In general, the rejection of N-nitrosamines increased when the membranes were fouled by tertiary effluent. The rejection of small molecular weight N-nitrosamines was most affected by membrane fouling. In particular, the rejection of N-nitrosodimethylamine (NDMA) by the ESPA2 membrane increased from 34 to 73% after membrane fouling caused by tertiary effluent. The results also indicate that the impact was less apparent for the lowest permeability membrane (i.e., ESPAB), and the rejection of N-nitrosamines by the ESPAB membrane was over 82% regardless of membrane fouling. The effect of membrane fouling caused by model foulants on N-nitrosamine rejection was considerably less than that caused by tertiary effluent. Size exclusion chromatography analyses revealed that the tertiary effluent contains a high fraction of low molecular weight (\u3c 500 g/mol) organic substances. It appears that these low molecular weight foulants present in the tertiary effluent can restrict the solute pathway within the active skin layer of membranes, resulting in the observed increase of solute rejection
N-nitrosamine rejection by reverse osmosis membranes: a full-scale study
This study aims to provide longitudinal and spatial insights to the rejection of N-nitrosamines by reverse osmosis (RO) membranes during sampling campaigns at three full-scale water recycling plants. Samples were collected at all individual filtration stages as well as at a cool and a warm weather period to elucidate the impact of recovery and feed temperature on the rejection of N-nitrosamines. N-nitrosodimethylamine (NDMA) was detected in all RO feed samples varying between 7 and 32 ng/L. Concentrations of most other N-nitrosamines in the feed solutions were determined to be lower than their detection limits (3e5 ng/L) but higher concentrations were detected in the feed after each filtration stage. As a notable exception, in one plant, N-nitrosomorpholine (NMOR) was observed at high concentrations in RO feed (177e475 ng/L) and permeate (34e76 ng/L). Overall rejection of NDMA among the three RO systems varied widely from 4 to 47%. Data presented here suggest that the feed temperature can influence rejection of NDMA. A considerable variation in NDMA rejection across the three RO stages (14e78%) was also observed. Overall NMOR rejections were consistently high ranging from 81 to 84%. On the other hand, overall rejection of N-nitrosodiethylamine (NDEA) varied from negligible to 53%, which was considerably lower than values reported in previous laboratory-scale studies. A comparison between results reported here and the literature indicates that there can be some discrepancy in N-nitrosamine rejection data between laboratory- and full-scale studies probably due to differences in water recoveries and operating conditions (e.g. temperature, membrane fouling, and hydraulic conditions)
Effects of membrane degradation on the removal of pharmaceutically active com#163s (PhACs) by NF/RO filtration processes
The impacts of membrane degradation due to chlorine attack on the rejection of pharmaceutically active compounds (PhACs) by nanofiltration and reverse osmosis membranes were investigated in this study. Membrane degradation was simulated by soaking the membranes in a sodium hypochlorite solution of various concentrations over 18 h. Changes in membrane surface properties were characterised by contact angle measurement, atomic force microscopy analysis, and streaming potential measurement. The impacts of hypochlorite exposure to the membrane separation processes were ascertained by comparing the rejection of PhACs by virgin and chlorine-exposed membranes. Overall, the reverse osmosis BW30 membrane and the tight nanofiltration NF90 membrane were much more resilient to chlorine exposure than the larger pore size TFC-SR2 and NF270 nanofiltration membranes. In fact, rejection of all three PhACs selected in this study by the BW30 remained largely unchanged after hypochlorite exposure and further characterisation did not reveal any evidence of compromised separation capability. In contrast, the effects of chlorine exposure to the two loose nanofiltration membranes were quite profound. While chlorine exposure generally resulted in reduced rejection of PhACs, a small increase in rejection was observed when a more dilute hypochlorite solution was used. Changes in the membrane surface morphology as well as observed rejection of inorganic salts and PhACs were found to be consistent with mechanisms of chlorine oxidation of polyamide membranes reported in the literature. Chlorine oxidation consistently resulted in a more negative zeta potential of all four membranes investigated in this study. Conformational alterations of the membrane polyamide active skin layer were also evident as reflected by changes in surface roughness before and after chlorine exposure. Such alterations can either loosen or tighten the effective membrane pore size, leading to either a decrease or an increase in rejection. Both of these phenomena were observed in this study, although the decrease in the rejection of PhACs was overwhelming from exposure to highly concentrated hypochlorite solution
Boron as a surrogate for N‑nitrosodimethylamine rejection by reverse osmosis membranes in potable water reuse applications
The results of this study reveal a strong linear correlation (R2 = 0.95) between the rejections of boron and N-nitrosodimethylamine (NDMA) by six different reverse osmosis (RO) membranes, suggesting that boron can be used as a surrogate for NDMA rejection. This proposal is based on the premise that the rejection of both boric acid and NDMA is governed by steric hindrance and that they have similar molecular dimensions. The concept proposed here is shown to be valid at pH 8 or below where boron exists as the neutral boric acid species and NDMA is also a neutral solute. Observed changes in the rejections of these two species, as a function of permeate fluxes and feed solution temperatures, were also almost identical. Boron rejection increased from 21 to 79%, and the correlation coefficient of the linear regression between boron and NDMA rejections was 0.99 as the permeate flux increased from 5 to 60 L m−2 h−1. Similarly, a linear correlation between boron and NDMA rejections was observed as the feed solution temperature increased from 10 to 40 °C. This linear correlation was also validated in a tertiary treated effluent matrix
Effects of feed solution characteristics on the rejection of N-nitrosamines by reverse osmosis membranes
The rejection of eight N-nitrosamines was investigated in this laboratory-scale study, focusing on the influence of feed solution characteristics on their separation by low pressure reverse osmosis membranes. The rejection mechanisms of N-nitrosamines were first examined using one nanofiltration (NF90) and two reverse osmosis (TFC-HR and SWC5) membranes. The TFC-HR membrane was used to investigate the effects of feed solution characteristics. The rejection of a particular N-nitrosamine was generally membrane dependent and increased in the order of NF (NF90), low pressure RO (TFC-HR) and seawater RO (SWC5) membranes. In general, the rejection of N-nitrosamines by a given membrane also increased in the order of increasing molecular weight. These results suggested that steric hindrance was a dominating rejection mechanism of N-nitrosamines. Nevertheless, it was also observed from the result of N-nitrosomorpholine (NMOR) that the rejection of N-nitrosamines may also depend on other physicochemical properties such as hydrophobicity. A decrease in the feed solution pH (from 9 to 3) resulted in a decrease in the rejection of the two smallest molecular weight N-nitrosamines, namely N-nitrosodimethylamine (NDMA) and N-nitrosomethylethylamine (NMEA). Changes in the feed solution ionic strength (from 26 to 260 mM) caused a discernible decrease only in NDMA rejection, while no apparent impact on rejection was observed for an increase in the feed concentration. On the other hand, it is striking that an increase in the feed temperature led to a significant decrease in the rejection of all N-nitrosamines and the impact was more pronounced for the small molecular weight N-nitrosamines. For example, a significant drop in NDMA rejection (from 49 to 25%) was observed as the feed temperature increased from 20 to 30 degrees C. The results also indicate that pH, ionic strength, and temperature of the feed solution can exert some influence on the rejection of NDMA and in some cases other N-nitrosamines. The combined effects of these feed solution characteristics, particularly feed temperature, may account for some of the variation of NDMA rejection by RO membranes previously reported in the literature