Performance analysis of two typical greenhouse lettuce production systems: Commercial hydroponic production and traditional soil cultivation

Introduction: Due to the shortage of land and water resource, optimization of systems for production in commercial greenhouses is essential for sustainable vegetable supply. The performance of lettuce productivity and the economic benefit in greenhouses using a soil-based system (SBS) and a hydroponic production system (HPS) were compared in this study. Methods: Experiments were conducted in two identical greenhouses over two growth cycles (G1 and G2). Three treatments of irrigation volumes (S1, S2, and S3) were evaluated for SBS while three treatments of nutrient solution concentration (H1, H2, and H3) were evaluated for HPS; the optimal levels from each system were then compared. Results and discussion: HPS was more sensitive to the effects of environmental temperature than SBS because of higher soil buffer capacity. Compared with SBS, higher yield (more than 134%) and higher water productivity (more than 50%) were observed in HPS. We detected significant increases in ascorbic acid by 28.31% and 16.67% and in soluble sugar by 57.84% and 32.23% during G1 and G2, respectively, compared with SBS. However, nitrate accumulated in HPS-grown lettuce. When the nutrient solution was replaced with fresh water 3 days before harvest, the excess nitrate content of harvested lettuce in HPS was removed. The initial investment and total operating cost in HPS were 21.76 times and 47.09% higher than those in SBS, respectively. Consideration of agronomic, quality, and economic indicators showed an overall optimal performance of the H2 treatment. These findings indicated that, in spite of its higher initial investment and requirement of advanced technology and management, HPS was more profitable than SBS for commercial lettuce production

Growth and Yield Response and Water Use Efficiency of Cotton under Film-Mulched Drip Irrigation to Magnetized Ionized Water and <i>Bacillus subtilis</i> in Saline Soil in Xinjiang

In irrigated agriculture, the combination of multiple regulation measures is an effective method to improve saline soil and promote crop growth. Magnetized ionized water irrigation is considered a promising irrigation water activation technique, while the use of Bacillus subtilis for soil amelioration is environmentally friendly. In this study, magnetized ionized water irrigation and B. subtilis were used to promote cotton growth under film-mulched drip irrigation (FMDI) in saline soil. A two-year field experiment was conducted to investigate the effects of differing B. subtilis amounts under two irrigation water types (non-magnetized-ionized water (NMIW) and magnetized ionized water (MIW)) on the growth (plant height, leaf area index, shoot dry matter and chlorophyll content) and the yield of cotton, as well as the soil water content, salts accumulation, water use efficiency (WUE) and irrigation water use efficiency (IWUE) under FMDI in a saline soil in southern Xinjiang. Five amounts of B. subtilis (0, 15, 30, 45 and 60 kg ha−1) under NMIW (designated as B0, B1, B2, B3 and B4) and MIW (designated as M, MB1, MB2, MB3 and MB4) were applied to the field experiments. The results showed that MIW and B. subtilis increased soil water content and reduced salts accumulation in the 0–40 cm soil layers compared with B0. Moreover, the two measures significantly (p p B. subtilis amount as an independent variable, quadratic function relationships with seed cotton yield, WUE and IWUE were established. By taking the first derivative of the quadratic function, the highest seed cotton yield, WUE and IWUE were obtained with the B. subtilis amounts of 51.8, 55.0 and 51.4 kg ha−1, respectively. Based on comprehensive consideration of seed cotton yield, WUE, IWUE and salts accumulation in soil, 51.4 kg ha−1 of B. subtilis under MIW treatment is recommended for cotton cultivated under FMDI in a saline soil of southern Xinjiang, China

Effects of foliage-applied exogenous γ-aminobutyric acid on seedling growth of two rice varieties under salt stress.

Exogenous γ-aminobutyric acid (GABA) has been used and regarded as a potential enhancer for plant resistance against various biotic or abiotic attackers in the crop production, especially as a promising alleviator against salt stress. In order to determine whether GABA is truly effective in promoting rice resistance under a certain level of salt stress or not and to evaluate its effect on the growth and some physiological responses of two Japonica rice varieties under salt stress. 3-leaf rice seedlings germinated from seeds were cultivated in a separate hydroponic cup with a nutrient solution that was salinized with 0, 25, 50, or 75 mmol K+ of NaCl. A 4 mmol L-1 GABA solution or water were sprayed onto leaves once a day for 8 days prior to an assessment of the seedling growth, the growth indices, root activities and three antioxidant enzyme activities in leaves were measured. Data analyses indicated that as the salt concentration increased, the plant height and the leaf area of both rice varieties decreased, while the dead leaf rate, weight ratio of the dry- and fresh-roots, superoxide dismutase (SOD) and peroxidase (POD) activities increased. Under the same saline conditions, the root activities and the leaf ascorbate peroxidase (APX) activity were enhanced at a low NaCl concentration but reduced when the salt concentration was high. A foliar application of GABA daily on both rice varieties for over a week under 3 different salinized treatments as compared with the corresponding treatments sprayed with water resulted in an enhanced effect on plant height increment by 1.7-32.4%, a reduction of dead leaf rate by 1.6-36.4%, a decline of root dry weight by 9.3-30.9% respectively, and an increment in root activities by 8.1-114.5%, and POD, SOD and APX enzyme activities increased by 5.0-33.3%, 4.1-18.5%, and 7.2-64.4% respectively. However, two rice varieties showed a significant difference in response to various salinized levels. Overall results of this study demonstrate that the application of exogenous GABA on the leaves of rice seedlings under salt stress has improved rice salt tolerance, which should provide a sufficient information for ultimately making it possible to grow rice in salinized soil

Effects of foliage-applied exogenous γ-aminobutyric acid on seedling growth of two rice varieties under salt stress

Exogenous γ-aminobutyric acid (GABA) has been used and regarded as a potential enhancer for plant resistance against various biotic or abiotic attackers in the crop production, especially as a promising alleviator against salt stress. In order to determine whether GABA is truly effective in promoting rice resistance under a certain level of salt stress or not and to evaluate its effect on the growth and some physiological responses of two Japonica rice varieties under salt stress. 3-leaf rice seedlings germinated from seeds were cultivated in a separate hydroponic cup with a nutrient solution that was salinized with 0, 25, 50, or 75 mmol K+ of NaCl. A 4 mmol L−1 GABA solution or water were sprayed onto leaves once a day for 8 days prior to an assessment of the seedling growth, the growth indices, root activities and three antioxidant enzyme activities in leaves were measured. Data analyses indicated that as the salt concentration increased, the plant height and the leaf area of both rice varieties decreased, while the dead leaf rate, weight ratio of the dry- and fresh-roots, superoxide dismutase (SOD) and peroxidase (POD) activities increased. Under the same saline conditions, the root activities and the leaf ascorbate peroxidase (APX) activity were enhanced at a low NaCl concentration but reduced when the salt concentration was high. A foliar application of GABA daily on both rice varieties for over a week under 3 different salinized treatments as compared with the corresponding treatments sprayed with water resulted in an enhanced effect on plant height increment by 1.7-32.4%, a reduction of dead leaf rate by 1.6-36.4%, a decline of root dry weight by 9.3-30.9% respectively, and an increment in root activities by 8.1-114.5%, and POD, SOD and APX enzyme activities increased by 5.0-33.3%, 4.1-18.5%, and 7.2-64.4% respectively. However, two rice varieties showed a significant difference in response to various salinized levels. Overall results of this study demonstrate that the application of exogenous GABA on the leaves of rice seedlings under salt stress has improved rice salt tolerance, which should provide a sufficient information for ultimately making it possible to grow rice in salinized soil

The Impact of Insect-Proof Screen on Microclimate, Reference Evapotranspiration and Growth of Chinese Flowering Cabbage in Arid and Semi-Arid Region

Despite the steadily increasing area under protected agriculture there is a current lack of knowledge about the effects of the insect-proof screen (IPS) on microclimate and crop water requirements in arid and semi-arid regions. Field experiments were conducted in two crop cycles in Ningxia of Northwest China to study the impact of IPS on microclimate, reference evapotranspiration (ET0) and growth of Chinese Flowering Cabbage (CFC). The results showed that IPS could appreciably improve the microclimate of the CFC field in the two crop cycles. During the first crop cycle (C1), compared with no insect-proof screen (NIPS) treatment, the total solar radiation and daily wind speed under the IPS treatment were reduced by 5.73% and 88.73%. IPS increased the daily average air humidity, air, and soil temperature during C1 by 11.84%, 15.11% and 10.37%, respectively. Furthermore, the total solar radiation and daily wind speed under the IPS treatment during the second crop cycle (C2) were markedly decreased by 20.45% and 95.73%, respectively. During C2, the daily average air temperature and air humidity under the IPS treatment were increased slightly, whereas the daily average soil temperature was decreased by 4.84%. Compared with NIPS treatment, the ET0 under the IPS treatment during C1 and C2 was decreased by 6.52% and 21.20%, respectively, suggesting it had great water-saving potential when using IPS. The plant height, leaf number and leaf circumference of CFC under the IPS treatment were higher than those under the NIPS treatment. The yield under the IPS treatment was significantly increased by 36.00% and 108.92% in C1 and C2, respectively. Moreover, irrigation water use efficiency (IWUE) was significantly improved under the IPS treatment in the two crop cycles. Therefore, it is concluded that IPS can improve microclimate, reduce ET0, and increase crop yield and IWUE in arid and semi-arid areas of Northwest China

Impacts of long-term saline water irrigation on soil properties and crop yields under maize-wheat crop rotation

Saline water is widely used as an alternative water resource for agriculture to overcome the freshwater shortage in arid and semiarid regions. But long-term using of the saline water for irrigation would negatively affect soil properties and crop production, and the salinity of the irrigation water should be properly managed to reduce the risks. In this study, saline water with five levels of electrical conductivities (ECiw) at 1.3 (CK), 3.4, 7.1, 10.6, and 14.1 dS·m−1 were used to irrigate winter wheat and summer maize with annual double cropping system in the North China Plain (NCP) from 2006 to 2019, to decide the threshold value for long-term using saline water. Crop yields and soil salinity were continuously examined from 2006 to 2019, and soil physicochemical properties were monitored in 2018 and 2019 after 12 years’ saline water irrigation. Results showed that soil salinity in the 0100 cm layer could be maintained at a low level using saline water with ECiw at 3.4 dS·m−1. Soil salt accumulated in winter wheat seasons could be leached from the main root zone in the following summer maize seasons, which were rainy in this region due to the monsoon climate. No significant difference was observed in grain yields for treatment with ECiw at 3.4 dS·m−1 compared to CK treatment. The electrical conductivity of the saturated soil extract (ECe), soil pH, sodium adsorption ratio, and bulk density within the top soil layer of 030 cm increased with the increase in ECiw, whereas the soil organic carbon, porosity, macroaggregates (> 0.25 mm) content, and activities of catalase, urease and alkaline phosphatase decreased, indicating the long-term using saline water irrigation deteriorated soil properties. But the difference in soil properties between the treatment of ECiw at 3.4 dS·m−1 and the CK was not apparent. There were reductions below 5% in relative grain yields and soil quality index (SQI) with ECiw lower than 3.17 and 3.10 dS·m−1 compared with CK treatment, respectively. Comprehensive consideration to maintain a stable crop production and benign soil quality, ECiw of 3.10 dS·m−1 for long-term saline water irrigation was recommended as the safe utilization threshold in the NCP

Fe–N–C single-atom catalysts with an axial structure prepared by a new design and synthesis method for ORR

Fe–N–C single-atom catalysts usually exhibit poor ORR activity due to their unsatisfactory O2 adsorption and activation. Here, a new design idea and tailored self-assembly synthesis method are reported to improve their ORR performance. DFT calculations indicate that the ORR electrocatalytic activity of Fe–N–C single-atom catalysts with an axial structure is superior to that of Fe–N–C single-atom catalysts with a Fe–N4 active site. In order to experimentally demonstrate the difference, Fe–N–C single-atom catalysts with a Fe–N5 active site were successfully synthesized on the surface of monolayer graphene. XANES, SEM, HRTEM, XRD, Raman and XPS analyses indicate that the synthesized Fe–N–C catalyst possessed nanofibre morphology and a curved layer-like crystal structure. For comparison, FePc powder was used as the FePc(Fe–N4) catalyst as its molecular structure involves a Fe–N4 active site embedded in carbon six-membered rings. The current density of the synthesized Fe–N5/C@G catalyst at a potential of 0.88 V vs. RHE is 1.65 mA cm−2, which is much higher than that of the FePc(Fe–N4) catalyst (1.04 mA cm−2) and even higher than that of commercial Pt/C catalyst (1.54 mA cm−2). The results are very well consistent with the DFT calculations, verifying the dependability and accuracy of DFT calculations. This work reports a new synthetic idea to obtain better performance and proposes a formation mechanism to explain the process of the synthesis method