Fundamentals of Liquid Phase Sintering During Selective Laser Sintering

One of the advantages of the Selective Laser Sintering (SLS) process is that a variety of materials can be processed. However, the goal of being able to produce fully dense metal parts with no post processing has been elusive. Using Selective Laser Sintering to produce metal parts with full density without post processing poses a challenge since both the processing conditions and the metal system must be controlled. This article describes two metallurgical mechanisms by which loose metal powder beds could be sintered to nearly full density using a scanning laser beam. The mechanisms are particle rearrangement during liquid phase sintering (LPS) and in-situ infiltration. Some of the particles, when heated by the laser radiation, melt and form a liquid. Ifthis liquid has certain physical properties (e.g., low viscosity and high surface tension) and wets the other solid particles, then the SLS process can in theory produce dense layers by either mechanism. The purpose of this study is to determine the process and material selection parameters required to achieve fully dense parts during direct Selective Laser Sintering of metal.Mechanical Engineerin

The Cholecystectomy As A Day Case (CAAD) Score: A Validated Score of Preoperative Predictors of Successful Day-Case Cholecystectomy Using the CholeS Data Set

Background Day-case surgery is associated with significant patient and cost benefits. However, only 43% of cholecystectomy patients are discharged home the same day. One hypothesis is day-case cholecystectomy rates, defined as patients discharged the same day as their operation, may be improved by better assessment of patients using standard preoperative variables. Methods Data were extracted from a prospectively collected data set of cholecystectomy patients from 166 UK and Irish hospitals (CholeS). Cholecystectomies performed as elective procedures were divided into main (75%) and validation (25%) data sets. Preoperative predictors were identified, and a risk score of failed day case was devised using multivariate logistic regression. Receiver operating curve analysis was used to validate the score in the validation data set. Results Of the 7426 elective cholecystectomies performed, 49% of these were discharged home the same day. Same-day discharge following cholecystectomy was less likely with older patients (OR 0.18, 95% CI 0.15–0.23), higher ASA scores (OR 0.19, 95% CI 0.15–0.23), complicated cholelithiasis (OR 0.38, 95% CI 0.31 to 0.48), male gender (OR 0.66, 95% CI 0.58–0.74), previous acute gallstone-related admissions (OR 0.54, 95% CI 0.48–0.60) and preoperative endoscopic intervention (OR 0.40, 95% CI 0.34–0.47). The CAAD score was developed using these variables. When applied to the validation subgroup, a CAAD score of ≤5 was associated with 80.8% successful day-case cholecystectomy compared with 19.2% associated with a CAAD score >5 (p < 0.001). Conclusions The CAAD score which utilises data readily available from clinic letters and electronic sources can predict same-day discharges following cholecystectomy

A comparison of high-frequency jet ventilation and synchronised intermittent mandatory ventilation in preterm lambs

Purpose: Synchronised intermittent mandatory ventilation (SIMV) and high-frequency jet ventilation (HFJV) are accepted ventilatory strategies for treatment of respiratory distress syndrome (RDS) in preterm babies. We hypothesised that SIMV and HFJV both facilitate adequate oxygenation and ventilation but that HFJV is associated with less lung injury. Results: There were no differences in arterial oxygenation or partial pressure of carbon dioxide despite lower mean airway pressure during SIMV for most of the study. There were no consistent significant differences in end systolic and end diastolic PBF, lung injury data and static lung compliance. Methods: Preterm lambs of anaesthetised ewes were instrumented, intubated and delivered by caesarean section after intratracheal suction and instillation of surfactant. Each lamb was managed for 3 hr according to a predetermined algorithm for ventilatory support consistent with open lung ventilation. Pulmonary blood flow (PBF) was measured continuously and pulsatility index was calculated. Ventilatory parameters were recorded and arterial blood gases were measured at intervals. At postmortem, in situ pressure-volume deflation curves were recorded, and bronchoalveolar lavage fluid and lung tissue were obtained to assess inflammation. Conclusions: SIMV and HFJV have comparable clinical efficacy and ventilator pressure requirements when applied with a targeted lung volume recruitment strategy

Evidence for circadian influence on human slow wave sleep during daytime sleep episodes

The occurrence of slow wave sleep within spontaneously initiated daytime sleep episodes was studied to examine hypothesized associations with prior wakefulness and circadian factors. There was a strong relationship between measures of slow wave sleep and the proximity of sleep episodes to the maximum of body core temperature. Those sleep episodes that began within 4 hours of the maximum in body core temperature contained significantly more slow wave sleep than did all other daytime sleep periods, approximating proportions typical of nocturnal sleep. Multiple regression analysis revealed no relationship between measures of slow wave sleep and prior wakefulness. These findings are consistent with an hypothesized approximately-12-hour rhythm in the occurrence of slow wave sleep and they underscore the influence imposed on human sleep by the endogenous circadian timing system

High positive end-expiratory pressure during high-frequency jet ventilation improves oxygenation and ventilation in preterm lambs

Increasing positive end-expiratory pressure (PEEP) is advocated to recruit alveoli during high-frequency jet ventilation (HFJV), but its effect on cardiopulmonary physiology and lung injury is poorly documented. We hypothesized that high PEEP would recruit alveoli and reduce lung injury but compromise pulmonary blood flow (PBF). Preterm lambs of anesthetized ewes were instrumented, intubated, and delivered by cesarean section after instillation of surfactant. HFJV was commenced with a PEEP of 5 cm H2O. Lambs were allocated randomly at delivery to remain on constant PEEP (PEEPconst, n = 6) or to recruitment via stepwise adjustments in PEEP (PEEPadj, n = 6) to 12 cm H2O then back to 8 cm H2O over the initial 60 min. PBF was measured continuously while ventilatory parameters and arterial blood gases were measured at intervals. At postmortem, in situ pressure-volume deflation curves were recorded, and bronchoalveolar lavage fluid and lung tissue were obtained to assess inflammation. PEEPadj lambs had lower pressure amplitude, fractional inspired oxygen concentration, oxygenation index, and PBF and more compliant lungs. Inflammatory markers were lower in the PEEPadj group. Adjusted PEEP during HFJV improves oxygenation and lung compliance and reduces ventilator requirements despite reducing pulmonary perfusion