63 research outputs found
Exploiting fatty acid metabolic pathway for production of short chain fatty acids in E. coli
Worldwide demand of sustainable fuels and chemicals has encouraged researchers for microbial synthesis of short chain fatty acids (SCFAs), such as such as butyric acid (C4), as they are attractive precursors to replace petroleum-based fuels and chemicals.
In this study, we explored the fatty acid metabolism for production of butyric acid in E. coli with the help of three thioesterases, i.e., TesAT from Anaerococcus tetradius, TesBF from Bryantella formatexigens and TesBT from Bacteroides thetaiotaomicron.
We found that E. coli strain transformed with gene for TesBT and grown in presence of 8 g/L glucose produced maximum butyric acid titer at 1.46 g/L, followed by that of TesBF at 0.85 g/L and TesAT at 0.12 g/L, showing that these thioesterases were efficiently converting short chain fatty acyl-ACP into corresponding acid. The titer of butyric acid varied significantly depending upon the strain genotype and plasmid copy number. Deletion of genes involved in initiating the fatty acid degradation such as fatty acyl-CoA synthetase and acyl-CoA dehydrogenase and overexpression of FadR, which is a dual transcriptional regulator, exerts negative control over fatty acid degradation pathway, reduced up to 30% of butyric acid titer. This observation suggested that β-oxidation pathway is working synergistically with fatty acid synthesis pathway in production of butyric acid. Moreover, accelerating the fatty acid elongation cycle by overexpressing acetyl-CoA carboxyltransferase (Acc) and 3-hydroxy-acyl-ACP dehydratase (FabZ) or by deleting FabR, the transcription suppressor of elongation, did not improve the butyric acid titer, rather favored the long chain fatty acid production. Use of chemical inhibitor cerulenin, which limits the fatty acid elongation cycle, increased the butyric acid titer by 1.7-fold in case of TesBF, while it had adverse impact in case of TesBT. In vitro enzyme assay showed that cerulenin also inhibited the short chain specific thioesterases, though inhibitory concentration varied according to the type of thioesterase used.
Further improvement in butyric acid was achieved by process optimization. Owing to the same pathway for both cell growth and butyric acid production, a balance was achieved between the two by growing the cells under nutrient and oxygen limiting condition. Keeping these factors in mind, a fed-batch cultivation strategy was devised for production of butyric acid in phosphorous and carbon limiting condition. Finally, we obtained 14.3 g/L of butyric acid and 17.5 g/L of total free fatty acid.
The strategy used in this study resulted in highest reported titers of butyric acid and free fatty acids in engineered E. coli and could be used to replace the traditional chemical methods for production of butyric acid
CRISPR/Cas9-mediated engineering of Escherichia coli for n-butanol production from xylose in defined medium.
Abstract
Butanol production from agricultural residues is the most promising alternative for fossil fuels. To reach the economic viability of biobutanol production, both glucose and xylose should be utilized and converted into butanol. Here, we engineered a dual-operon-based synthetic pathway in the genome of E. coli MG1655 to produce n-butanol using CRISPR/Cas9 technology. Further deletion of competing pathway followed by fed-batch cultivation of the engineered strain in a bioreactor with glucose-containing complex medium yielded 5.4 g/L n-butanol along with pyruvate as major co-product, indicating a redox imbalance. To ferment xylose into butanol in redox-balanced manner, we selected SSK42, an ethanologenic E. coli strain engineered and evolved in our laboratory to produce ethanol from xylose, for integrating synthetic butanol cassette in its genome via CRISPR/Cas9 after deleting the gene responsible for endogenous ethanol production. The engineered plasmid- and marker-free strain, ASA02, produced 4.32 g/L butanol in fed-batch fermentation in completely defined AM1–xylose medium
Calcium-dependent permeabilization of erythrocytes by a perforin-like protein during egress of malaria parasites.
Clinical malaria is associated with proliferation of blood-stage parasites. During the blood stage, Plasmodium parasites invade host red blood cells, multiply, egress and reinvade uninfected red blood cells to continue the life cycle. Here we demonstrate that calcium-dependent permeabilization of host red blood cells is critical for egress of Plasmodium falciparum merozoites. Although perforin-like proteins have been predicted to mediate membrane perforation during egress, the expression, activity and mechanism of action of these proteins have not been demonstrated. Here, we show that two perforin-like proteins, perforin-like protein 1 and perforin-like protein 2, are expressed in the blood stage. Perforin-like protein 1 localizes to the red blood cell membrane and parasitophorous vacuolar membrane in mature schizonts following its Ca(2+)-dependent discharge from micronemes. Furthermore, perforin-like protein 1 shows Ca(2+)-dependent permeabilization and membranolytic activities suggesting that it may be one of the effector proteins that mediate Ca(2+)-dependent membrane perforation during egress
Biochemical, biophysical, and functional characterization of bacterially expressed and refolded receptor binding domain of Plasmodium vivax duffy-binding
Invasion of erythrocytes by malaria parasites is mediated by specific molecular interactions. Plasmodium vivax is completely dependent on interaction with the Duffy blood group antigen to invade human erythrocytes. The P. vivax Duffy-binding protein, which binds the Duffy antigen during invasion, belongs to a family of erythrocyte-binding proteins that also includesPlasmodium falciparum sialic acid binding protein andPlasmodium knowlesi Duffy binding protein. The receptor binding domains of these proteins lie in a conserved, N-terminal, cysteine-rich region, region II, found in each of these proteins. Here, we have expressed P. vivax region II (PvRII), the P. vivax Duffy binding domain, in Escherichia coli. Recombinant PvRII is incorrectly folded and accumulates in inclusion bodies. We have developed methods to refold and purify recombinant PvRII in its functional conformation. Biochemical, biophysical, and functional characterization confirms that recombinant PvRII is pure, homogeneous, and functionally active in that it binds Duffy-positive human erythrocytes with specificity. Refolded PvRII is highly immunogenic and elicits high titer antibodies that can inhibit binding of P. vivax Duffy-binding protein to erythrocytes, providing support for its development as a vaccine candidate forP. vivax malaria. Development of methods to produce functionally active recombinant PvRII is an important step for structural studies as well as vaccine development
Model-assisted metabolic engineering of Escherichia coli for long chain alkane and alcohol production
Biologically-derived hydrocarbons are considered to have great potential as next-generation biofuels owing to the similarity of their chemical properties to contemporary diesel and jet fuels. However, the low yield of these hydrocarbons in biotechnological production is a major obstacle for commercialization. Several genetic and process engineering approaches have been adopted to increase the yield of hydrocarbon, but a model driven approach has not been implemented so far. Here, we applied a constraint-based metabolic modeling approach in which a variable demand for alkane biosynthesis was imposed, and co-varying reactions were considered as potential targets for further engineering of an E. coli strain already expressing cyanobacterial enzymes towards higher chain alkane production. The reactions that co-varied with the imposed alkane production were found to be mainly associated with the pentose phosphate pathway (PPP) and the lower half of glycolysis. An optimal modeling solution was achieved by imposing increased flux through the reaction catalyzed by glucose-6-phosphate dehydrogenase (zwf) and iteratively removing 7 reactions from the network, leading to an alkane yield of 94.2% of the theoretical maximum conversion determined by in silico analysis at a given biomass rate. To validate the in silico findings, we first performed pathway optimization of the cyanobacterial enzymes in E. coli via different dosages of genes, promoting substrate channelling through protein fusion and inducing substantial equivalent protein expression, which led to a 36-fold increase in alka(e)ne production from 2.8 mg/L to 102 mg/L. Further, engineering of E. coli based on in silico findings, including biomass constraint, led to an increase in the alka(e)ne titer to 425 mg/L (major components being 249 mg/L pentadecane and 160 mg/L heptadecene), a 148.6-fold improvement over the initial strain, respectively; with a yield of 34.2% of the theoretical maximum. The impact of model-assisted engineering was also tested for the production of long chain fatty alcohol, another commercially important molecule sharing the same pathway while differing only at the terminal reaction, and a titer of 1506 mg/L was achieved with a yield of 86.4% of the theoretical maximum. Moreover, the model assisted engineered strains had produced 2.54 g/L and 12.5 g/L of long chain alkane and fatty alcohol, respectively, in the bioreactor under fed-batch cultivation condition. Our study demonstrated successful implementation of a combined in silico modeling approach along with the pathway and process optimization in achieving the highest reported titers of long chain hydrocarbons in E. coli
Accessory enzymes of hypercellulolytic Penicillium funiculosum facilitate complete saccharification of sugarcane bagasse
BACKGROUND: Sugarcane bagasse (SCB) is an abundant feedstock for second-generation bioethanol production. This complex biomass requires an array of carbohydrate active enzymes (CAZymes), mostly from filamentous fungi, for its deconstruction to monomeric sugars for the production of value-added fuels and chemicals. In this study, we evaluated the repertoire of proteins in the secretome of a catabolite repressor-deficient strain of Penicillium funiculosum, PfMig188, in response to SCB induction and examined their role in the saccharification of SCB. RESULTS: A systematic approach was developed for the cultivation of the fungus with the aim of producing and understanding arrays of enzymes tailored for saccharification of SCB. To achieve this, the fungus was grown in media supplemented with different concentrations of pretreated SCB (0-45 g/L). The profile of secreted proteins was characterized by enzyme activity assays and liquid chromatography-tandem mass spectrometry (LC-MS/MS). A total of 280 proteins were identified in the secretome of PfMig188, 46% of them being clearly identified as CAZymes. Modulation of the cultivation media with SCB up to 15 g/L led to sequential enhancement in the secretion of hemicellulases and cell wall-modifying enzymes, including endo-β-1,3(4)-glucanase (GH16), endo-α-1,3-glucanase (GH71), xylanase (GH30), β-xylosidase (GH5), β-1,3-galactosidase (GH43) and cutinase (CE5). There was ~ 122% and 60% increases in β-xylosidase and cutinase activities, respectively. There was also a 36% increase in activities towards mixed-linked glucans. Induction of these enzymes in the secretome improved the saccharification performance to 98% (~ 20% increase over control), suggesting their synergy with core cellulases in accessing the recalcitrant region of SCB. CONCLUSION: Our findings provide an insight into the enzyme system of PfMig188 for degradation of complex biomass such as SCB and highlight the importance of adding SCB to the culture medium to optimize the secretion of enzymes specific for the saccharification of sugarcane bagasse
Mining the biomass deconstructing capabilities of rice yellow stem borer symbionts
Efficient deconstruction of lignocellulosic biomass into simple sugars in an economically viable manner is a prerequisite for its global acceptance as a feedstock in bioethanol production. This is achieved in nature by suites of enzymes with the capability of efficiently depolymerizing all the components of lignocellulose. Here we provide detailed insight into the repertoire of enzymes produced by microorganisms enriched from the gut of the crop pathogen rice yellow stem borer ( Scirpophaga insertulas ). Results: A microbial community was enriched from the gut of the rice yellow stem borer for enhanced rice straw degradation by sub-culturing every 10 days, for one year, in minimal medium with rice straw as the main carbon source. The enriched culture demonstrated high cellulolytic and xylanolytic activity in the culture supernatant. Metatranscriptomic and metaexoproteomic analysis revealed a large array of enzymes potentially involved in rice straw deconstruction. The consortium was found to encode genes ascribed to all 5 class of carbohydrate active enzymes (GHs, GTs, CEs, PLs and AAs), including Carbohydrate-Binding Modules (CBMs), categorized in the Carbohydrate-Active enZYmes (CAZy) database. The GHs were the most abundant class of CAZymes. Predicted enzymes from these CAZy classes have the potential to digest each cell wall components of rice straw i.e. cellulose, hemicellulose, pectin, callose and lignin. Several identified CAZy proteins appeared novel, having an unknown or hypothetical catalytic counterpart with a known class of CBM. To validate the findings, one of the identified enzymes that belongs to the GH10 family was functionally characterized. The enzyme expressed in E. coli efficiently hydrolyzed beechwood xylan, and pretreated and untreated rice straw. Conclusions: This is the first report describing the enrichment of lignocellulose degrading bacteria from the gut of the rice yellow stem borer to deconstruct rice straw, identifying a plethora of enzymes secreted by the microbial community when growing on rice straw as a carbon source. These enzymes could be important candidates for biorefineries to overcome the current bottlenecks in biomass processing
Comparative insights into the saccharification potentials of a relatively unexplored but robust Penicillium funiculosum glycoside hydrolase 7 cellobiohydrolase
- …