Influence of Apple Cultivars on Inactivation of Different Strains of Escherichia coli O157:H7 in Apple Cider by UV Irradiation

This study examined the effect of different apple cultivars upon the UV inactivation of Escherichia coli O157:H7 strains within unfiltered apple cider. Apple cider was prepared from eight different apple cultivars, inoculated with approximately 10(6) to 10(7) CFU of three strains of E. coli O157:H7 per ml (933, ATCC 43889, and ATCC 43895), and exposed to 14 mJ of UV irradiation per cm(2). Bacterial populations for treated and untreated samples were then enumerated by using nonselective media. E. coli O157:H7 ATCC 43889 showed the most sensitivity to this disinfection process with an average 6.63-log reduction compared to an average log reduction of 5.93 for both strains 933 and ATCC 43895. The highest log reduction seen, 7.19, occurred for strain ATCC 43889 in Rome cider. The same cider produced the lowest log reductions: 5.33 and 5.25 for strains 933 and ATCC 43895, respectively. Among the apple cultivars, an average log reduction range of 5.78 (Red Delicious) to 6.74 (Empire) was observed, with two statistically significant (α ≤ 0.05) log reduction groups represented. Within the paired cultivar-strain analysis, five of eight ciders showed statistically significant (α ≤ 0.05) differences in at least two of the E. coli strains used. Comparison of log reductions among the E. coli strains to the cider parameters of °Brix, pH, and malic acid content failed to show any statistically significant relationship (R(2) ≥ 0.95). However, the results of this study indicate that regardless of the apple cultivar used, a minimum 5-log reduction is achieved for all of the strains of E. coli O157:H7 tested

Stability of alternariol and alternariol monomethyl ether during food processing of tomato products

The stability of two Alternaria mycotoxins, alternariol (AOH) and alternariol monomethyl ether (AME), has been investigated during the food processing of tomato products simulating commercial processing conditions. The production stages assessed were the storage of raw fruits, fruit washing, and thermal processing. It was observed that time of storage significantly reduced the initial concentration of AOH, but only if tomatoes were stored at 35 °C. For AME, 12 h were sufficient to reduce the initial concentration, regardless of the temperature at which samples were stored (25, 30 and 35 °C). The washing step achieved the highest reduction of AOH and AME. This reduction was even more efficient when using sodium hypochlorite solutions. Finally, during the heat treatment (80-110 °C), results showed that heating tomato samples at 100 and 110 °C, significantly affected AOH stability, though AME seemed to not be affected by these thermal processe

Inactivation of Cryptosporidium parvum Oocysts in Fresh Apple Cider by UV Irradiation

This study evaluated the efficacy of UV irradiation on the inactivation of Cryptosporidium parvum oocysts in fresh apple cider. Cider was inoculated with oocysts and exposed to 14.32 mJ of UV irradiation/cm(2). Oocyst viability was assessed with the gamma interferon gene knockout (GKO) mouse and infant BALB/cByJ mouse models. All GKO mice challenged with UV-treated cider demonstrated no morbidity or mortality, and infant BALB/c mice challenged with treated cider were negative for the presence of C. parvum. In contrast, the GKO mice challenged with non-UV-treated inoculated cider died and the parasite was detected in the ileums of all challenged infant mice. This study shows that UV irradiation can be used to inactivate C. parvum in fresh apple cider

The effectiveness of treating irrigation water using ultraviolet radiation or sulphuric acid fertilizer for reducing generic Escherichia coli on fresh produce—a controlled intervention trial

Aims The aims of this study were to: (i) estimate the effectiveness of ultraviolet radiation (UV) and sulphuric acid-based fertilizer (SA), at reducing levels of generic Escherichia coli in surface irrigation water and on produce and surface soil in open produce fields; and (ii) describe the population dynamics of generic E. coli in produce fields. Methods and Results Spinach and cantaloupe plots were randomly assigned to control, UV or SA treatment groups. Irrigation water was inoculated with Rifampicin-resistant E. coli prior to treatment. More than 75% of UV- and SA-treated tank water samples had counts below the detection limit, compared to a mean count of 3·3 Log10 CFU per ml before treatment. Levels of Rifampicin-resistant E. coli in soil and produce both increased and decreased over 10–15 days after irrigation, depending on the plot and time-period. Conclusions UV and SA treatments effectively reduce the levels of E. coli in surface irrigation water. Their effectiveness at reducing contamination on produce was dependent on environmental conditions. Applying wait-times after irrigation and prior to harvest is not a reliable means of mitigating against contaminated produce. Significance and Impact of the Study The results are of timely importance for the agricultural industry as new FSMA guidelines require producers to demonstrate a low microbial load in irrigation water or allow producers to apply a wait-time to mitigate the risk of contaminated produce.Universidad de Costa Rica/[735-B6-777]/UCR/Costa RicaUCR::Vicerrectoría de Investigación::Unidades de Investigación::Ciencias Agroalimentarias::Centro Nacional de Ciencia y Tecnología de Alimentos (CITA