Effect of Gas Atmosphere on Catalytic Behaviour of Zirconia, Ceria and Ceria Zirconia Catalysts in Valeric Acid Ketonization

[EN] Ketonization of valeric acid, which can be obtained by lignocellulosic biomass conversion, was carried out in a fixed bed flow reactor over ZrO2, 5-20 % CeO2/ZrO2 and CeO2 both under hydrogen and nitrogen stream at 628 K and atmospheric pressure. Regardless gas-carrier 10 wt% CeO2/ZrO2 was found to show higher catalytic activity compared to zirconia per se as well as other ceria modified zirconia while ceria per se exhibited very low catalytic activity. All catalysts provided higher acid conversion in H-2 than in N-2 whereas selectivity to 5-nonanone was insensitive to gas atmosphere. XRD, FTIR, UV-Vis DRS, XPS, HRTEM methods were applied to characterize catalysts in reduced and unreduced states simulating corresponding reaction conditions during acid ketonization. XRD did not reveal any changes in zirconia and ceria/zirconia lattice parameters as well as crystalline phase depending on gas atmosphere while insertion of ceria in zirconia caused notable increase in lattice parameter indicating some distortion of crystalline structure. According to XPS, FTIR and UV-Vis methods, the carrier gas was found to affect catalyst surface composition leading to alteration in Lewis acid sites ratio. Appearance of Zr3+ cations was observed on the ZrO2 surface after hydrogen pretreatment whereas only Zr4+ cations were determined using nitrogen as a gas-carrier. These changes of catalyst's surface cation composition affected corresponding activity in ketonization probably being crucial for reaction mechanism involving metal cations catalytic centers for acid adsorption and COO- stabilization at the initial step.Financial support from the Russian Foundation of Basic Research (RFBR Grant No 11-03-94001-CSIC) is gratefully acknowledged. This work was supported by the Federal Program "Scientific and Educational Cadres of Russia'' (Grant No 2012-1.5-12-000-1013-002). The authors also wish to thank Dr. Evgeniy Gerasimov, Dr. Igor Prosvirin, Dr. Demid Demidov from the Department of Physicochemical Methods at the Boreskov Institute of Catalysis for TEM and XPS measurements.Zaytseva, YA.; Panchenko, VN.; Simonov, MN.; Shutilov, AA.; Zenkovets, GA.; Renz, M.; Simakova, IL.... (2013). Effect of Gas Atmosphere on Catalytic Behaviour of Zirconia, Ceria and Ceria Zirconia Catalysts in Valeric Acid Ketonization. Topics in Catalysis. 56(9-10):846-855. https://doi.org/10.1007/s11244-013-0045-yS846855569-10Alonso DM, Bond JQ, Dumesic JA (2010) Green Chem 12:1493–1513Serrano-Ruiz JC, Wang D, Dumesic JA (2010) Green Chem 12:574–577Malhotra SL, Wong RW, Breton MP (2002) Patent US 6461417Westfechtel A, Breucker C, Gutsche B, Jeromin L, Eierdanz H, Baumann H, Schmid KH, Nonnenkamp W (1993) Patent DE 4121117Seipel W, Hensen H, Boyxen N (2001) Patent DE 19958521Tomlinson AD (2001) Patent WO 2001094522Glinski M, Kijenski J, Jakubowski A (1995) Appl Catal A Gen 128:209–217Glinski M, Kijenski J (2000) React Kinet Catal Lett 69:123–128Parida K, Mishra HK (1999) J Mol Catal A Chem 139:73–80Serrano-Ruiz JC, Dumesic JA (2009) Green Chem 11:1101–1104Serrano-Ruiz JC, Dumesic JA (2009) ChemSusChem 2:581–586Leung A, Boocock DGB, Konar SK (1995) Energy Fuels 9:913–920Gaertner CA, Serrano-Ruiz JC, Braden DJ, Dumesic JA (2010) Ind Eng Chem Res 49:6027–6033Saito N (1996) Patent JP 08198796Yakerson VI, Rubinshtein AM, Gorskaya LA (1970) Patent GB 1208802Graille J, Pioch D (1991) Patent EP 457665Pioch D, Lescure R, Graille J (1995) Ol Corps Gras Lipides 2:386–389Mueller-Erlwein E, Rosenberger B (1990) Chem Ing Tech 62:512–513Corma A, Renz M, Schaverien C (2008) ChemSusChem 1:739–741Bayer (1911) Patent DE 256622Vavon G, Apchie A (1928) Bull Soc Chim 43:667–677Thorpe JF, Kon GAR (1941) Org Synth 1:192–194Nagashima O, Sato S, Takahashi R, Sodesawa T (2005) J Mol Catal A Chem 227:231–239Klein-Homann W (1988) Patent DE 3709765Stubenrauch J, Brisha E, Vohs JM (1996) Catal Today 28:431–441Pulido A, Oliver-Tomas B, Renz M, Boronat M, and Corma A (2013) ChemSusChem 6:141–151Hendren TS, Dooley KM (2003) Catal Today 85:333–351Novothy R, Paulsen S (1963) Patent DE 1158050Kim KS, Barteau MA (1990) J Catal 125:353–375Pestman R, Van Duijne A, Pieterse JAZ, Ponec V (1995) J Mol Catal A 103:175–180Martinez R, Huff MC, Barteau MA (2004) J Catal 222:404–409Matsuoka K, Tagawa K (1985) Patent JP 61207354Shutilov AA, Simonov MN, Zaytseva YuA, Zenkovets GA, and Simakova IL (2013) Kinet Catal 54:184–192Kuriacose JC, Swaminathan R (1969) J Catal 14:348–354Swaminathan R, Kuriacose JC (1970) J Catal 16:357–362Cressely J, Farkhani D, Deluzarche A, Kiennemann A (1984) Mater Chem Phys 11:413–431Kuriacose JC, Jewur SS (1977) J Catal 50:330–341Renz M, Corma A (2004) Eur J Org Chem 2004:2036–2039Taimoor AA, Favre-Reguillon A, Vanoye L, Pitault I (2012) Catal Sci Technol 2:359–363Kustov LM (1997) Top Catal 4:131–144Emmanuel NM (1978) Usp Khim 8:1329–1396Kaspar J, Fornasiero P (2002) In: Trovarelli A (ed) Catalysis by ceria and related materials. Imperial College Press, LondonReddy DD, Chowdhury B, Smirniotis PG (2001) Appl Catal A Gen 211:19–30Rango R, Kaspar G, Meriani S, di Monte R, Graziani M (1994) Catal Lett 24:107–112Rao G, Sahu H (2001) Proc Indian Acad Sci (Chem Sci) 113:651–658Navío JA, Hidalgo MC, Colón G, Botta SG, Litter MI (2001) Langmuir 17:202–210Timofeeva MN, Jhung SH, Hwang YK, Kim DK, Panchenko VN, Melgunov MS, Chesalov YA, Chang JS (2007) Appl Catal A Gen 317:1–10Kaneko H, Taku S, Tamaura Y (2011) Sol Energy 85:2321–2330Maia TA, Assaf JM, Assaf EM (2012) Mater Chem Phys 132:1029–1034Zhou HP, Si R, Song WG, Yan CH (2009) J Solid State Chem 182:2475–2485Si R, Zhang YW, Li SJ, Lin BX, Yan CH (2004) J Phys Chem B 108:12481–12488Hadjivanov KI, Vayssilov GN (2002) Adv Catal 47:307–511Vivier L, Duprez D (2010) ChemSusChem 3:654–678Vidruk R, Landau MV, Herskowitz M, Ezersky V, Goldbourt A (2011) J Catal 282:215–227Binet C, Daturi M, Lavalley JC (1999) Catal Today 50:207–225Conesa J (1995) Surf Sci 339:337–35

Conversion of CO₂, CO, and H₂ in CO₂ Hydrogenation to Fungible Liquid Fuels on Fe-Based Catalysts

CO₂ hydrogenation conducted on Fe-based catalysts consists of a wide range of reactions with CO₂ and H₂ reacting in the reverse water–gas shift (RWGS) to produce CO and CO and H₂ reacting in the Fischer–Tropsch (FT) type reactions leading to hydrocarbons and oxygenates. Methanation and Boudouard side reactions are extremely detrimental to selectivity and stability of the Fe-based catalysts. The catalytic system is very complex, posing challenging issues that require fundamental understanding of the dynamics of changes in the catalytic phases, mechanism of key reactions, and effects of catalyst composition including key promoters. A comprehensive analysis of fundamental aspects of catalytic materials, phases, and promoters and the catalytic mechanisms are presented in this paper. It was established that the ratio of Fe_carbide/Fe_oxide atoms at the surface of an activated catalyst responsible for its selectivity is determined by the environment of iron ions in oxide precursors changed by insertion of ions of other metals. Fungible liquid fuels were produced in bench scale reactors and demonstrated to be suitable as blending stock for transportation fuels. The techno-economic analysis of processes using CO₂ and either water, biogas, or natural gas as feedstock was conducted. As expected, the production of eco-friendly, renewable fuels based on CO₂ is not competitive with fuels based on crude oil because of the high cost of production of hydrogen

Hierarchical Zeolitic Imidazolate Framework-8 Catalyst for Monoglyceride Synthesis

INGENIERIE+TLE:DF

Life-long impairment of hypoxic phrenic responses in rats following 1 month of developmental hyperoxia

Hypoxic ventilatory and phrenic responses are reduced in adult rats (3–5 months old) exposed to hyperoxia for the first month of life (hyperoxia treated). We previously reported that hypoxic phrenic responses were normal in a small sample of 14- to 15-month-old hyperoxia-treated rats, suggesting slow, spontaneous recovery. Subsequent attempts to identify the mechanism(s) underlying this spontaneous recovery of hypoxic phrenic responses led us to re-evaluate our earlier conclusion. Experiments were conducted in two groups of aged Sprague-Dawley rats (14–15 months old) which were anaesthetized, vagotomized, neuromuscularly blocked and ventilated: (1) a hyperoxia-treated group raised in 60 % O2 for the first 28 postnatal days; and (2) an age-matched control group raised in normoxia. Increases in minute phrenic activity and integrated phrenic nerve amplitude (∫Phr) during isocapnic hypoxia (arterial partial pressures of O2, 60, 50 and 40 ± 1 mmHg) were greater in aged control (n = 15) than hyperoxia-treated rats (n = 11; P≤ 0.01). Phrenic burst frequency during hypoxia was not different between groups. To examine the central integration of carotid chemoafferent inputs, steady-state relationships between carotid sinus nerve (electrical) stimulation frequency and phrenic nerve activity were compared in aged control (n = 7) and hyperoxia-treated rats (n = 7). Minute phrenic activity, ∫Phr and burst frequency were not different between groups at any stimulation frequency between 0.5 and 20 Hz. Carotid body chemoreceptor function was examined by recording whole carotid sinus nerve responses to cessation of ventilation or injection of cyanide in aged control and hyperoxia-treated rats. Electrical activity of the carotid sinus nerve did not change in five out of five hyperoxia-treated rats in response to stimuli that evoked robust increases in carotid sinus nerve activity in five out of five control rats. Estimates of carotid body volume were lower in aged hyperoxia-treated rats (4.4 (± 0.2) × 106μm3) compared to controls (17.4 (± 1.6) × 106μm3; P <0.01). We conclude that exposure to hyperoxia for the first month of life causes life-long impairment of carotid chemoreceptor function and, consequently, blunted phrenic responses to hypoxia