40 research outputs found

    Self-limiting low-temperature growth of crystalline AIN thin films by plasma-enhanced atomic layer deposition

    Get PDF
    Cataloged from PDF version of article.We report on the self-limiting growth and characterization of aluminum nitride (AlN) thin films. AlN films were deposited by plasma-enhanced atomic layer deposition on various substrates using trimethylaluminum (TMA) and ammonia (NH3). At 185 degrees C, deposition rate saturated for TMA and NH3 doses starting from 0.05 and 40 S. respectively. Saturative surface reactions between TMA and NH3 resulted in a constant growth rate of similar to 0.86 angstrom/cycle from 100 to 200 degrees C. Within this temperature range, film thickness increased linearly with the number of deposition cycles. At higher temperatures (>= 225 degrees C) deposition rate increased with temperature. Chemical composition and bonding states of the films deposited at 185 degrees C were investigated by Xray photoelectron spectroscopy. High resolution Al 2p and N 1s spectra confirmed the presence of AlN with peaks located at 73.02 and 396.07 eV, respectively. Films deposited at 185 degrees C were polycrystalline with a hexagonal wurtzite structure regardless of the substrate selection as determined by grazing incidence X-ray diffraction. High-resolution transmission electron microscopy images of the AlN thin films deposited on Si (100) and glass substrates revealed a microstructure consisting of nanometer sized crystallites. Films exhibited an optical band edge at similar to 5.8 eV and an optical transmittance of >95% in the visible region of the spectrum. (C) 2011 Elsevier B.V. All rights reserved

    Atomic layer deposition of GaN at low temperatures

    Get PDF
    Cataloged from PDF version of article.The authors report on the self-limiting growth of GaNthin films at low temperatures. Films were deposited on Si substrates by plasma-enhanced atomic layer deposition using trimethylgallium (TMG) and ammonia (NH3) as the group-III and -V precursors, respectively. GaNdeposition rate saturated at 185 °C for NH3 doses starting from 90 s. Atomic layer deposition temperature window was observed from 185 to ∼385 °C. Deposition rate, which is constant at ∼0.51 Å/cycle within the temperature range of 250 – 350 °C, increased slightly as the temperature decreased to 185 °C. In the bulk film, concentrations of Ga, N, and O were constant at ∼36.6, ∼43.9, and ∼19.5 at. %, respectively. C was detected only at the surface and no C impurities were found in the bulk film. High oxygen concentration in films was attributed to the oxygen impurities present in group-V precursor. High-resolution transmission electron microscopy studies revealed a microstructure consisting of small crystallites dispersed in an amorphous matrix

    Generation of InN nanocrystals in organic solution through laser ablation of high pressure chemical vapor deposition-grown InN thin film

    Get PDF
    Cataloged from PDF version of article.We report the synthesis of colloidal InN nanocrystals (InN-NCs) in organic solution through nanosecond pulsed laser ablation of high pressure chemical vapor deposition-grown InN thin film on GaN/sapphire template substrate. The size, the structural, the optical, and the chemical characteristics of InN-NCs demonstrate that the colloidal InN crystalline nanostructures in ethanol are synthesized with spherical shape within 5.9-25.3, 5.45-34.8, 3.24-36 nm particle-size distributions, increasing the pulse energy value. The colloidal InN-NCs solutions present strong absorption edge tailoring from NIR region to UV region. © 2012 Springer Science+Business Media B.V

    Structural properties of AlN films deposited by plasma-enhanced atomic layer deposition at different growth temperatures

    Get PDF
    Crystalline aluminum nitride (AlN) films have been prepared by plasma-enhanced atomic layer deposition (PEALD) within the temperature range from 100 to 500 °C. A self-limiting, constant growth rate per cycle temperature window (100-200 °C) was established which is the major characteristic of an ALD process. At higher temperatures (>225 °C), deposition rate increased with temperature. Chemical composition, crystallinity, surface morphology, mass density, and spectral refractive index were studied for AlN films. X-ray photoelectron spectroscopy (XPS) analyses indicated that besides main Al-N bond, the films contained Al-O-N, Al-O complexes, and Al-Al metallic aluminum bonds as well. Crystalline hexagonal AlN films were obtained at remarkably low growth temperatures. The mass density increased from 2.65 to 2.96 g/cm 3 and refractive index of the films increased from 1.88 to 2.08 at 533 nm for film growth temperatures of 100 and 500 °C, respectively. Copyright © 2012 WILEY-VCH Verlag GmbH & Co. KGaA, Weinheim

    Optical properties of AlN thin films grown by plasma enhanced atomic layer deposition

    Get PDF
    Crystalline aluminum nitride (AlN) films have been prepared by plasma enhanced atomic layer deposition within the temperature range of 100 and 500 °C. The AlN films were characterized by x-ray diffraction, spectroscopic ellipsometry, Fourier transform infrared spectroscopy, optical absorption, and photoluminescence. The authors establish a relationship between growth temperature and optical properties and in addition, the refractive indices of the AlN films were determined to be larger than 1.9 within the 300-1000 nm wavelength range. Infrared reflectance spectra confirmed the presence of E 1(TO) and A 1(LO) phonon modes at ∼660 cm -1 and 895 cm -1, respectively. Analysis of the absorption spectroscopy show an optical band edge between 5.78 and 5.84 eV and the absorption and photoluminescence emission properties of the AlN layers revealed defect centers in the range of 250 and 300 nm at room temperature. © 2012 American Vacuum Society

    A Near-Infrared Range Photodetector Based on Indium Nitride Nanocrystals Obtained Through Laser Ablation

    Get PDF
    Cataloged from PDF version of article.We present a proof-of-concept photodetector that is sensitive in the near-infrared (NIR) range based on InN nanocrystals. Indium nitride nanocrystals (InN-NCs) are obtained through laser ablation of a high pressure chemical vapor deposition grown indium nitride thin film and are used as optically active absorption region. InN-NCs are sandwiched between thin insulating films to reduce the electrical leakage current. Under -1 V applied bias, the recorded photoresponsivity values within 600-1100-nm wavelength range are as high as 3.05 x 10(-2) mA/W. An ultrathin layer of nanocrystalline InN thin film is, therefore, a promising candidate for NIR detection in large area schemes. © 2014 IEEE

    Enhanced memory effect via quantum confinement in 16 nm InN nanoparticles embedded in ZnO charge trapping layer

    Get PDF
    Cataloged from PDF version of article.In this work, the fabrication of charge trapping memory cells with laser-synthesized indium-nitride nanoparticles (InN-NPs) embedded in ZnO charge trapping layer is demonstrated. Atomic layer deposited Al2O3 layers are used as tunnel and blocking oxides. The gate contacts are sputtered using a shadow mask which eliminates the need for any lithography steps. High frequency C-Vgate measurements show that a memory effect is observed, due to the charging of the InN-NPs. With a low operating voltage of 4 V, the memory shows a noticeable threshold voltage (Vt) shift of 2 V, which indicates that InN-NPs act as charge trapping centers. Without InN-NPs, the observed memory hysteresis is negligible. At higher programming voltages of 10 V, a memory window of 5 V is achieved and the Vt shift direction indicates that electrons tunnel from channel to charge storage layer. © 2014 AIP Publishing LL

    Comparison of trimethylgallium and triethylgallium as "ga" source materials for the growth of ultrathin GaN films on Si (100) substrates via hollow-cathode plasma-assisted atomic layer deposition

    Get PDF
    GaN films grown by hollow cathode plasma-assisted atomic layer deposition using trimethylgallium (TMG) and triethylgallium (TEG) as gallium precursors are compared. Optimized and saturated TMG/TEG pulse widths were used in order to study the effect of group-III precursors. The films were characterized by grazing incidence x-ray diffraction, atomic force microscopy, x-ray photoelectron spectroscopy, and spectroscopic ellipsometry. Refractive index follows the same trend of crystalline quality, mean grain, and crystallite sizes. GaN layers grown using TMG precursor exhibited improved structural and optical properties when compared to GaN films grown with TEG precursor. © 2015 American Vacuum Society

    Generation of InN nanocrystals in organic solution through laser ablation of high pressure chemical vapor deposition-grown InN thin film

    Get PDF
    We report the synthesis of colloidal InN nanocrystals (InN-NCs) in organic solution through nanosecond pulsed laser ablation of high pressure chemical vapor deposition-grown InN thin film on GaN/sapphire template substrate. The size, the structural, the optical, and the chemical characteristics of InN-NCs demonstrate that the colloidal InN crystalline nanostructures in ethanol are synthesized with spherical shape within 5.9-25.3, 5.45-34.8, 3.24-36 nm particle-size distributions, increasing the pulse energy value. The colloidal InN-NCs solutions present strong absorption edge tailoring from NIR region to UV region. © 2012 Springer Science+Business Media B.V
    corecore