Offline Chemical Wash for Internal Fouled Multistage Pump

Case StudiesHigh pressure lean amine pump performance dropped within a span of about 1 month due to internal fouling. Fouling was caused by accumulation of iron sulphide. To address the fouling, pump would have been to taken out of service for a full overhaul, resulting in extended downtime and high cost of repair. Offline chemical wash with 1% EDTA (Ethylenediaminetetraacetic) solution pursued as an alternative to the pump overhaul. Prior to commencing with the chemical wash, material compatibility of pumps/mechanical seals wetted parts, and process fluid flow path were considered as part of the technical evaluation. The chemical wash skid comprised of an external circulation tank and air operated diaphragm pump. Skid was connected to the pump via flexible hoses. During chemical wash, samples were regularly collected at the circulation outlet to check for appearance in order to determine progress of the chemical wash in removing the foulants. Pump performance recovered upon completion of the chemical wash

Steam Turbine High Axial Displacement due to Governor Actuator Filter Clog

Case StudiesThe governor actuator for a steam turbine was observed to be hunting and failed to maintain stable operating speed. The steam turbine is used to drive a centrifugal compressor for H2 service in a recycle loop. The extent of speed oscillating was exaggerating over time and caused excessive turbine axial movement. The unit was forced to shut down to prevent secondary damage due to turbine high axial movement. The steam turbine was overhauled approximately 9 months prior to the incident. Oil flushing was performed, lube oil was changed out and main oil filters were replaced as part of machinery overhaul scope. The main oil filter elements were inspected during troubleshooting of this event and were badly fouled with blackish substance. The governor actuators were inspected and the internal filters for the oil supply line were clogged with soft, blackish substance. Foulant analysis was performed using Energy Dispersive X-ray (EDX) which identified the main component to be Carbon. De- gassing tank oil was drained out and observed layer of blackish substance. EDX identified the main component to be identical to that found in main oil filter. Water sample from de-gassing tank bottom drain was tested and the pH was 3-4 (i.e. acidic). Further troubleshooting revealed that fine carbon particles were carried over from upstream and mixing with the process gas prior to the unit shut down for the compressor train overhaul. The presence of carbon particles had contaminated the seal oil and control oil circuit which then clogged up the actuator internal fine filters (~40um). This case study presents the unusual phenomenon, troubleshooting tools, recovery process and key learnings which provide user operating with similar service a reference

The Effect of Atmospheric Cold Plasma Treatment on the Antigenic Properties of Bovine Milk Casein and Whey Proteins

Casein, β-lactoglobulin and α-lactalbumin are major milk protein allergens. In the present study, the structural modifications and antigenic response of these bovine milk allergens as induced by non-thermal treatment by atmospheric cold plasma were investigated. Spark discharge (SD) and glow discharge (GD), as previously characterized cold plasma systems, were used for protein treatments. Casein, β-lactoglobulin and α-lactalbumin were analyzed before and after plasma treatment using SDS-PAGE, FTIR, UPLC-MS/MS and ELISA. SDS-PAGE results revealed a reduction in the casein and α-lactalbumin intensity bands after SD or GD treatments; however, the β-lactoglobulin intensity band remained unchanged. FTIR studies revealed alterations in protein secondary structure induced by plasma, particularly contents of β-sheet and β-turn. The UPLC-MS/MS results showed that the amino acid compositions decreased after plasma treatments. ELISA of casein and α-lactalbumin showed a decrease in antigenicity post plasma treatment, whereas ELISA of β-lactoglobulin showed an increase in antigenicity. The study indicates that atmospheric cold plasma can be tailored to mitigate the risk of bovine milk allergens in the dairy processing and ingredients sector

GAS TURBINE COMPRESSOR INLET AIR FILTERS PERFORMANCE COMPARISON

Case Studie

Room-temperature InP/InGaAs nano-ridge lasers grown on Si and emitting at telecom bands

Semiconductor nano-lasers grown on silicon and emitting at the telecom bands are advantageous ultra-compact coherent light sources for potential Si-based photonic integrated circuit applications. However, realizing room-temperature lasing inside nano-cavities at telecom bands is challenging and has only been demonstrated up to the E band. Here, we report on InP/InGaAs nano-ridge lasers with emission wavelengths ranging from the O, E, and S bands to the C band operating at room temperature with ultra-low lasing thresholds. Using a cycled growth procedure, ridge InGaAs quantum wells inside InP nano-ridges grown on patterned (001) Si substrates are designed as active gain materials. Room-temperature lasing at the telecom bands is achieved by transferring the InP/InGaAs nano-ridges onto a SiO2∕Si substrate for optical excitation. We also show that the operation wavelength of InP/InGaAs nano-lasers can be adjusted by altering the excitation power density and the length of the nano-ridges formed in a single growth run. These results indicate the excellent optical properties of the InP/InGaAs nano-ridges grown on (001) Si substrates and pave the way towards telecom InP/InGaAs nano-laser arrays on CMOS standard Si or silicon-on-insulator substrates

Cell Death Induced in Glioblastoma Cells by Plasma-Activated-Liquids (PAL) is Primarily Mediated by Membrane Lipid Peroxidation and not ROS Influx

Since first identified in 1879, plasma, the fourth state of matter, has been developed and utilised in many fields. Nonthermal atmospheric plasma, also known as cold plasma, can be applied to liquids, where plasma reactive species such as reactive Oxygen and Nitrogen species and their effects can be retained and mediated through plasma-activated liquids (PAL). In the medical field, PAL is considered promising for wound treatment, sterilisation and cancer therapy due to its rich and relatively long-lived reactive species components. This study sought to identify any potential antagonistic effect between antioxidative intracellularly accumulated platinum nanoparticles (PtNPs) and PAL. We found that PAL can significantly reduce the viability of glioblastoma U-251MG cells. This did not involve measurable ROS influx but instead lead to lipid damage on the plasma membrane of cells exposed to PAL. Although the intracellular antioxidative PtNPs showed no protective effect against PAL, this study contributes to further understanding of principle cell killing routes of PAL and discovery of potential PAL-related therapy and methods to inhibit side effects

Cold Atmospheric Plasma Stimulates Clathrin-Dependent Endocytosis to Repair Oxidised Membrane and Enhance Uptake of Nanomaterial in Glioblastoma Multiforme Cells

peer-reviewedCold atmospheric plasma (CAP) enhances uptake and accumulation of nanoparticles and promotes synergistic cytotoxicity against cancer cells. However, the mechanisms are not well understood. In this study, we investigate the enhanced uptake of theranostic nanomaterials by CAP. Numerical modelling of the uptake of gold nanoparticle into U373MG Glioblastoma multiforme (GBM) cells predicts that CAP may introduce a new uptake route. We demonstrate that cell membrane repair pathways play the main role in this stimulated new uptake route, following non-toxic doses of dielectric barrier discharge CAP. CAP treatment induces cellular membrane damage, mainly via lipid peroxidation as a result of reactive oxygen species (ROS) generation. Membranes rich in peroxidised lipids are then trafficked into cells via membrane repairing endocytosis. We confirm that the enhanced uptake of nanomaterials is clathrin-dependent using chemical inhibitors and silencing of gene expression. Therefore, CAP-stimulated membrane repair increases endocytosis and accelerates the uptake of gold nanoparticles into U373MG cells after CAP treatment. We demonstrate the utility of CAP to model membrane oxidative damage in cells and characterise a previously unreported mechanism of membrane repair to trigger nanomaterial uptake. This knowledge will underpin the development of new delivery strategies for theranostic nanoparticles into cancer cells

A new record of the spiny lobster, Panulirus femoristriga (von Martens, 1872) from the coastal waters of Malaysia, with revision of global distribution

Background Spiny lobsters of the family Palinuridae Latreille, 1802 are known to be industrial crustaceans in the global fishing market amongst other crustacean marine species. Panulirus femoristriga has been reported in the Maldives, Japan, Taiwan, Vietnam, the Philippines, Indonesia (Ambon, Irian Jaya, Celebes Island, Seram Island), the Polynesian Islands, Solomon Islands, New Hebrides, Wallis and Futuna and off the coast of northern Australia, but there is uncertainty about their distributions due to the morphological similarity with Panulirus femoristriga, Panulirus longipes bispinosus and Panulirus brunneiflagellum. However, the identification on P. femoristiga can only be confirmed if the morphological descriptions are mentioned in literature

DNA metabarcoding unravels unknown diversity and distribution patterns of tropical freshwater invertebrates

Tropical freshwater invertebrate species are becoming extinct without being described, and effective conservation is hampered by a lack of taxonomic and distribution data. DNA metabarcoding is a promising tool for rapid biodiversity assessments that has never been applied to tropical freshwater invertebrates across large spatial and taxonomic scales. Here we use DNA metabarcoding to comprehensively assess the benthic freshwater invertebrate fauna of the Perak River basin, Malaysia. Specific objectives were to: (1) assess performance of two DNA metabarcoding protocols; (2) identify gaps in reference databases; (3) generate new data on species diversity and distribution; and (4) draw conclusions regarding the potential value of DNA metabarcoding in tropical freshwater conservation. Organisms were collected by hand and net at 34 sites and divided into small (retained in 0.5-mm but passing through 1-mm mesh) and large (retained in 1-mm mesh) fractions, and a 313-bp cytochrome c oxidase subunit I fragment amplified and sequenced using general Metazoa primers. Bioinformatic analysis resulted in 468 operational taxonomic units (~species) from 12 phyla. Only 29% of species could be assigned binominal names through matches to public sequence libraries, indicating varying levels of library completeness across Orders. Extraction of small-fraction DNA with a soil kit resulted in a significantly higher species count than with a general kit, but this was not even across taxa. Metabarcoding (amplification) success rate, estimated via comparison to morphological identifications of the large-fraction specimens, was high in most taxa analysed but low, for example, in ampullariid and viviparid gastropods. Conversely, a large proportion of species-site records for Decapoda and Bivalvia came from metabarcoding only. Species richness averaged 29 ± 16 species per site, dominated by Diptera, Annelida, and Odonata, and was particularly high in tributaries of the mountainous Titiwangsa Range. At least eight species are new records for Malaysia, including the non-natives Ferrissia fragilis (Gastropoda) and Dugesia notogaea (Platyhelminthes). Our study showed that DNA metabarcoding is generally more effective in detecting tropical freshwater invertebrate species than traditional morphological approaches, and can efficiently improve knowledge of distribution patterns and ranges of native and non-native species. However, current gaps in reference databases, particularly for bioindicator taxa, such as the Plecoptera, Ephemeroptera, and Coleoptera, need to be addressed urgently

2D materials for conducting holes from grain boundaries in perovskite solar cells

Grain boundaries in organic-inorganic halide perovskite solar cells (PSCs) have been found to be detrimental to the photovoltaic performance of devices. Here, we develop a unique approach to overcome this problem by modifying the edges of perovskite grain boundaries with flakes of high-mobility two-dimensional (2D) materials via a convenient solution process. A synergistic effect between the 2D flakes and perovskite grain boundaries is observed for the first time, which can significantly enhance the performance of PSCs. We find that the 2D flakes can conduct holes from the grain boundaries to the hole transport layers in PSCs, thereby making hole channels in the grain boundaries of the devices. Hence, 2D flakes with high carrier mobilities and short distances to grain boundaries can induce a more pronounced performance enhancement of the devices. This work presents a cost-effective strategy for improving the performance of PSCs by using high-mobility 2D materials