HOLLÓ, J.

LENGYEL, T.

UZONYI, H. M.

English

Periodica Polytechnica (Budapest University of Technology and Economics)

INVESTIGATION ON THE SYSTEM TRIETHYL AMINE-ACETIC ACID By J. HOLLO, T. LENGYEL and H. M. UZONYI Institute for Agricultural Chemical Technology, Polyterhnical"Uni .... ersity, Budape"t (Received January 26, 1960) Introduction GARDNER [1] was the first to call attention to the system triethyl amine-acetic acid. After a fairly long time, this mixture of special behaviour, was inve-stigated by VAN KLOOSTER and DOUGLAS [2] who pointed out that the system has only partial miscibility and at a concentration of 21 mole % of triethyl amine it forms a negative azeotrope. It is worth mentioning that the region of limited mi..xing lies between the concentration of 40 and 95 mole % of triethyl amine, consequently the development of the azeotrope is not directly connected ·with the formation of the two liquid phases. The anomalistic trend of the equili-brium curve suggests the extreme case of the negative homoazeotropes and at the same time, it can be considered as being the opposite analogue of the positive heteroazeotropes developing in case of components absolutely insoluble in each other [3]. VAN KLOOSTER and DOUGLAS strived to explain this phenomenon with the dimerization of the acetic acid and by supposing the formation of a com-pound to be characterized by the composition 4CH3COOH. N(C2H 5)3; other--wise, the existence of ionic compounds of such a type developing between aromatic amines and acetic acid was obsen-ed by others, too [4, 5]. In this Institute the vapour-liquid equilibria of carboxylic acids were investigated recently. The association taking place in these systems certainly plays a role also in case of the acetic acid; therefore, besides its general interest, the system triethyl amine-acetic acid was considered to be suitable for studying simultaneously the general behaviour of the carboxylic acids, too. Experimental During the investigations chemicals of analytical purity were used. For analysis of the system measurements of refractivity were employed obtaining suitable accuracy with a relative error of 1 %. In case of heterogeneous mixtures, acetic acid of known quantity ·was added to a definite quantity of the sample and the refractive index of the homogeneous mixture developed 1 Periodica Polytechnica Ch. IV/3. 174 J. HOLLO. T. LESGYEL and H . . 1[. UZOSYI I fDCl f40 !30 120 fiG 100 \ gO 80 I \ 70 !)L; ~'O ,0 \ 30 0,5 9,6 0,7 0,8 ~. Fig. 1. Solubility diagram of the system triethyl amine-acetic acid as a fUllction of the triethyl amine concentration ili ,......--------------~ f,O 0,9 OB '7 v" Q,6 0,5 O,lf 0,3 D) 0,2 0.4 06 Fig. 2. Equilibrium diagram of the system triethyl amine - acetic acid o 760 torr V 380 torr X 190 torr o 95 torr + 47.5 torr ISVESTIGATIOS OS TlIE :iY';TE.H TRIETHYL AJIISE-·ACETIC ACID 175 in such way was dctermined: from this yalue the original composition could be determined. _1 modified \VILLIA2IIs-type apparatus was used for the equilibrium mcasure-ments. The function of this apparatus was described in detail prcyiously [6]. The solubility of the system was determined, in the usual way, using sealed ampoules. At higher temperatures the determination 'was also performed in !~J~-----------------------' no 160 150 14D 130 120 110 100 gO 0.2 0.5 0,8 Xi Fig. 3. Boiling-point diagram of the system triethyl amine-acetic acid an open vessel, in order to eliminate the possible error due to the vapour pres-sure of the system itself, but the so obtained results were identical with those gained by the other method. The measured solubility diagram of the system is shown in Fig. 1. The full line is traced on the basis of VAN KLOOSTER'S and DOUGLAS' measurements, while the points inscribed represent the authors' measuring results. The equilibrium data obtained at a pressure of 760 torr are summarized in Table I as well as in Figs. 2 and 3. For the sake of comparison, in Fig. 2 the equilibrium data gained at pressures of 380, 190, 95, and 47.5 torr are also shown. The trend of the equilibrium curve is very similar to the above-mentioned authors' results [2J but, according to our resnlts, the steep portion of the curve appears at a triethyl amine concentration of 24, mole %, and not at 21 mole %. 1* 176 J. HOLLO, T. LE!SGYEL and H. M. UZONYI Table I Yapour-liquid equilibrium of the system triethyl amine-acetic acid at 760 torr Xi Yi l('e) 0,037 0,001 120,0 0,052 0,001 121,2 0,108 0,002 128,1 0,112 0,002 129,0 0,141 0,003 132,5 0,179 0,004 142,0 0,205 0,006 152.9 0.219 0,011 155.3 0.226 0,348 156,0 0.235 0,519 158.9 0.260 0,983 162,0 0.275 0,983 142,1 0,299 0,984 122,5 0,345 0,987 96,8 0,525 0,991 89,7 0,650 0,990 89,8 0,825 0.995 89.6 0.910 0,998 89,5 0.951 0,999 89,5 Evaluation of the experimental results From the yap our-liquid equilibrium data and the steep portion of the curve, respectively, the conclusion can be drawn that, in contrast to VAN KLOOSTER'S and DOUGLAS' statements, the establishment of the triethyl aminc -acetic acid complex is closer to the molar ratio of 1 to 3 (25 mole % of triethyl amine). The results of the measurcments carried out in yacuum refer to the fact that the complex having a molar ratio of 1 : 3 can be revealed at each pressure and that its composition, respectively, undergoes practically no change. This statement points to the presence of a compound, because in case of an azeo-trope the composition ought to be shifted by such a considerable change in pressure. Mention must be made of the fact that the existence of this complex ha'dng the composition of 3CHsCOOH . N(C2H 5)3 can more easily be explained 'with the formation of hydrogen-bonds than the existence of the ionic compound containing 4 moles of acetic acid. INVESTIGATIOX OX THE SYSTE.1f TRIETHYL A.1fINE-ACETIC ACID 177 As was sho'wn by several authors, in the vapour phase, the acetic acid is pre5ent in oligomeric form. By measuring the vapour density, in acetic acid vapour the presence of trimeric and tetrameric molecules was proved, besides the dimeric ones [7, 8, 9, 10], while in equilibrium measurements it was stated recently [11, 12, 13] that, in accordance with the results of infrared and Raman spectroscopy [14], it is sufficient to take only the dimerization into considera-tion. In compliance with the afore-said, to correlate the vapour-liquid equili-brium data obtained in the experimental way, the Raoult-Dalton law corrected only with the activity coefficient cannot be used, and the introduction of other correction factors seems also to be necessary. The consistency of selected points on the smoothed equilibrium curve drawn on the basis of the measuring data was controlled bv the following general equation: (1) where P = total pressure of the system Xi = molar fraction of component i in the vapour phase Zi = correction factor for the behaviour of component i in the vapour phase (z factor) ~i = correction factor for association of component i in the vapour phase Pi = vapour preS5ure of component i di = correction factor for the vapour pressure of component partly dimerized Xi = molar fraction of component i in the liquid phase ri = activity coefficient of component i and }'i = correction factor for association of component i m the liquid phase. With this general equation also the association can be taken into account; thus the validity of the equation comprises the non-hildebrandian mLxtures too. During the computations the vapour pressure of the acetic acid partly dimerized was considered on the basis of MAREK'S data [15]; the literature data concerning the vapour pressure of triethyl amine are partly contradictory and partly incorrect [16, 17]. The relation 1161.4 log Ptriethy) amine = 6.8264 - ----. (205+t) was found to be the most correct [I8]. i78 J. HOLLO. T. LESGYEL and H . . H. (:ZOSY1 To calculate the correction factor ;;;, including the non-ideal behayiour of the yapour phase, SCHEIBEL'S following equation [l9J was used: where Vi = volume of component i corrected to the appropriate temperature with WATSO;-.;'S equation [20J and Pi = second virial coefficient of component i calculated for the indi-vidual points with BERTHELOT'S relation [3J judged to be the most suitable: 27 RT1 64?[i T~ where R = uniyersal gas constant Ti = critical temperature of component i Ti = critical pressure of component i and T = prevailing temperature. The value taking the association occurring in the yap our phase into account was calculated for the associating component (acetic acid) with :MAREK's following equation: where K = equilibrium constant for the associating reaction of acetic acid in case of pure acetic acid and K2 = the same yalue in the giyen mixture, The remaining signs are the same as stated aboye. For calculating the correction factor relating to the non-associating component (triethyl amine) and yalid because of the association of the acetic acid occurring in the yapour phase, :MAREK's equation was employed [12] as welL according to which 2 [1 - Y 2 VI +TI(~(2 -=)'J] (2 Jz) [l + Vi + 4KPY2 (2 - Y2) ] The association equilibrium constants \\'ere taken into account on the basis of literature data [15]. The values obtained after substitutions for the products of multiplica-tion 1'; and ;" are shown in Table n. The change of the products with compo:;:i-tion is shown in Fig. 4. I.YVESTIGATIOJS O,Y THE SYSTE.'l-f TRIEHTYL .·LVIE\T-ACETIC ACID 179 Table IT Yalues of the correction factors for the vapour-liquid equilibrium of the system triethyl amine -acetic acid as a function of the concentration x, y, :, :~ >, ;'li'l i':!i.:: 0,050 0,001 120,9 1,0837 1,0017 1,61 0,38 O.OH 1,01l 0,100 0,002 127,0 1,1380 1,0063 1,57 0,43 0,013 1.009 0,200 0,004 152,5 L2450 1,0396 1.27 0,72 0,006 0,708 0,220 0,201 155,5 l.2335 1.0369 l.06 0,76 0,229 0,676 0,230 0,520 160,0 1,2042 L0300 1,00 0,97 0,552 0,600 0,260 0.983 162,5 Ll246 1,01l4 1,00 0,94 1,354 0,038 0,310 0.985 115.1 1,0348 0,9900 1,00 0,78 l.793 0.081 0,410 0,988 90.0 1,0001 0,9807 1,00 0.63 2.376 0.109 0,520 0,991 89,7 1,0000 0.9806 1,00 0,69 1,880 0.112 0,650 0.993 89.6 0,9999 0,9805 1,00 0.72 L522 i 0.124 0,800 0,995 89,5 0,9998 0,9804 LOO 0,76 1,246 0.165 0,950 0,999 89,5 0,9998 0.9804 1.00 0.90 1,050 0.154 From the Figure it appears that the function of the composition of the activity coefficients (more correctly speaking, the values gained from tht' product of the association factor valid in the liquid phase and of the corre-sponding activity coefficient) is formed in conformity with a minimum and a !J,), (12')2) 2,4 2,2 2,0 ~8 1,6 1,2 to 08 0,6 0,4 Q2 _......;~"'"..l.=.2_X __ X 0,2 0.4 0,6 0,8 X, Fig. 4. \' airH's of the products Yi j'i as a function of the triethyl-amine concentration 180 J. HOLLO, T. LE.YGYEL and H . • H. [:ZO:"1'1 maximum curve, respectively, thus, with this method thermodynamically inconsistent data are obtained. It is worth mentioning that, in spite of this fact, the curves satisfy the requirement of approaching 1 in case of the limit-ing concentrations. The intersection to be seen in Fig. ,1 of the activity coefficients and the results of multiplication )li i'i' respectively, the corresponding abscissa value of 'which, according to HOGFELDT [21], furnishes, in the case of formation of a compound, information concerning the composition of the compound, appears at a concentration of 24 mole of triethyl amine. This value approaches 'wen / qf 0,2 D,J 0,4 0,5 0,6 G,7 0,8 0,9 xifYil Fig. 5. Reduction of the apparent triethyl amine concentration appearing in the pseudobinary system triethyl amine-acetic acid to real binary molar fractions Abscissa pertaining to eurve 1: molar fraction of triethyl amine in the system triethyl amine -3CH3COOH. N(C2HSh Abscissa pertaining to curve 2: molar fraction of acetic acid in the system acetic acid-3CH3COOH· ~(C2H5h the composition of the compound postulated above and characterized with the formula 3CHaCOOH . ~(C2H5h. It is here to be mentioned that the determination of the degree of associa-tion in the liquid phase would be very complicated and would be equivalent to the separated determination of )li from the results )li i'i' Unfortunately, the trend of the curves of Fig. 4 cannot substantially be influenced by this separated determination and the separation of the correction factor for the association in the liquid phase, from the result of multiplication mentioned above, does not render the values consistent of the activity coef-ficients. Further, investigations were carried out in connection with the question whether the pseudobinary system triethyl amine-acetic acid can he considered as the mixture of two binary systems, namely of the system triethyl amine -3CH3COOH. N(C2H 3)3 and of the system acetic acid-3CH3COOH. ISVESTIGATIOS OS THE SYSTEM TRIETHYL A.1fI:YE-ACETIC ACID 18 I · )i(CZH5)3' Starting from the given experimental data, to decide this question, calculations were carried out in connection with the equilibrium of the t"WO systems. The diagrams making possible the conversion from the pseudobinary system to the two binary systems were plotted (Fig. 5), and determining ebulliometrically the yapour pressure of the compound 3CH3COOH· · N(C2H5h (Fig. 6), the yalues of the activity coefficients were calculated for different liquid compo;;itions. In case of the system acetic acid-3CH3COOH . · N(C9 H-).,. the Cllryes aiying the change of the activity coefficients with the ~ a v' 0 ~ ~ composition show a minimum-maximum trend; in case of the system triethyl Torr 800 600 500 400 JOO 200 100 80 60 50 "0 / /' , '" !/ : : / I ! i ; i i ; I ~., !/ I , . /""1 / / ! --, ! i I , I i I I i I ! I 90 100 110 120 130 fltO f50 f50 t fCC; Fig. 6. Vapour pressure of the compound 3CH3COOH·N (CZH5h amine-3CH3COOH . N(C2H5b the curves showed no extreme yalue, while-the activity coefficient of the compound 3CH3COOH. N(C2H 5)3 converged to zero instead of 1 at the triethyl amine coneentration of zero, which fact cannot be physically interpreted. Summary Investigations were carried out in connection with the vapour-liquid equilibrium of the system triethyl amine-acetic acid. After determining the equilibrium curve of the ex-tremely non-ideal system, "with the aid of an extremely general equation, computations were carried out to determine the thermodynamical consistency of the experimental results. The calculations closed with a negative result, and the authors only succeeded in giving the probable formation of the compound 3CH3COOH. X(CzHs>S. Literature 1. GARDNER, J. A.: Ber. 23, 1507 (1891). 2. VAN KLOOSTER, H. S. and DOUGLAS, W. A.: J. Phys. Chem. 49, 67 (1945). 3. NYUL, Gy.: "Leparhis", l\Hisz. Kk., Budapest, 1955. 182 .T. HOLLO, T. LE.YGYEL and H. Jf. UZO.YYI 4. LUCASSE, W-. \\'., KOOB, R. P. and MILLER, J. G.: J. Phys. Chem. 48, 85 (194,1). 5. O'CON:,\,OR, J.: J. Chem. Soc. 125, 1422 (1924). 6. HOLLo,J. and LENGYEL, T.: Bp. Miisz. Egy. ~fezogazd. Kern. Techn. Tsz. Kiizl. 2, 1 (1958) 7. ~L-icDOUGALL, F. 2\1.: J. Am. Chem. Soc. 58, 2585 (1936). 8. RITTER, H. L. and Smoxs, J. H.: J. Am. Chem. Soc. 67, 757 (1945). 9. JOH:'\'SON. E. W. and NASH, L. K.: J. Am. Chem. Soc. 72, 547 (1950). 10. TAYLOR. 1L D.: J. Am. Chem. Soc. 73, 315 (1951). 11. GARNER, F. H., ELLIS, S. R. :)I. and PEARCE, C. J.: Chem. Eng. Science 3, 48 (1954). 12. MAREK, J. and STANDARD, G.: ColI. Czech. Chem. Comm. 19, 1074 (1954). 13. ZIEBORAK, K. and BRZOSTOWSKI, W.: Bull. Acad. Polon. Sci. Cl. III 6, 169 (1958). 14. WELTNER, W.: J. Am. Chem. Soc. 77, 3941 (1955). 15. MAREK, J.: Col!. Czech. Chem. Comm. 20, 14·90 (1955). 16. JORDAN, T. E.: Vapor Pressure of Organic Compounds, Interscience Ltd., New York, 1954. 17. COPP, J. L. and EVERETT, D. H.: Disc. Faraday Soc. 15, 174 (1953). 18. LA:'\'GE, 1\'. A.: Handbook of Chemistry, 9th ed., Handbook PubL Ohio, 1956. 19. SCHEIBEL. E. G.: Ind. Eng. Chem. 41, 1076 (1949). 20. WATSO:,\" K. ~L: Ind. Eng. Chem. 35, 398 (1943). 21. HOGFELDT, E.: Acta Chem. Scand. 5, 1400 (1951). Prof. J. HOLLO 1 T. LEl';'GYEL H. :.vI. tTZOC'iYI f Budapest, XI., GelIert ter 4. Hungary. 

INVESTIGATION ON THE SYSTEM TRIETHYL AMINEACETIC ACID

https://pp.bme.hu/ch/article/download/3658/2763

INVESTIGATION ON THE SYSTEM TRIETHYL AMINEACETIC ACID

Abstract

Similar works

Full text

Available Versions

Periodica Polytechnica (Budapest University of Technology and Economics)