Nicholaichuk, W.

English

University of Saskatchewan Research Archive

- 158 -SEEPAGE CONTROL IN FARM-SIZED DUGOUTS W. Nicholaichukl INTRODUCTION The farm dugout offers the only means of water supply in many areas where groundwater is either unsuitable or non-existent. In some instances, particularly in area~ where the soil tends to be calcareous, these earthen water impoundments are subject to excessive seepage losses. Many methods of seepage control have been suggested. They include the use of lining materials such as concrete, polymer films, butyl rubber and bentonite. Apart from certain problems associated with each of the four mentioned lining materials, they are considered to be generally expensive.. Other methods that may be advantageous economically, but are not as well publicized include the use of chemical reagents and organic liners. The chemical characteristics of the· soil often have more inflJlence on permeability than texture. Excessive concentrations of calcium cause clay particles in the soil to aggregate and to form a porous water stable structure with high permeability characteristics. This undesirable property can be rectified by replacing the calci~ with sodium. Sodium ions cause aggregates to disperse, thereby reducing the permeability' of clay. Reginato et al. (1968) describe a_method of using sodium car-bonate to reduce water loss and give equations for determining the . amount of chemical required based on the cation exchange capacity of the soil. Na2co3 = 0.0428 DA (0.15 CEC - ES) where Na2C03.= grams of sodium carbonate; D =depth of soil treated (em); A== area to be treated (m2); CEC =cation exchange capacity Emeq/lOOg); ES • exchangeabl~ sodium (meq/100 g). The above formula facilitates calculation of the quantity of sodium carbonate required to raise exchangeable sodium percentage from its original value to 15 (designated by ~he factor of 0.15) assuming complete replacement by sodium'. Graveland (1973) has found in a labor-atory study that increasing the application rate resulted in decreasing. the hydraulic conductivity to a levelling point that coin-cided with actual exchangeable sodium percentage of 15. This point was achieved by using a coefficient of 0.25 in the application rate equation. !Research Scientist, Research Station, Research Branch, Agriculture Canada, Swift Current, Saskatchewan. - 159 -\ Anoth~r ch~mical m~thod of r~tarding g~~page ~ag by th~ ug~ of a patented chemical, SS-13, manufactured by Laurtan of Anaheim, Cali-fornia. A report prepared by the manufacturer claims that application of the chemical will normally reduce seepage losses to a range of 0.05 to 0.30 cu. ft. of water/sq. ft. of wetted soil area per day which is equivalent to 0.06 to 0.38 em/hr. A new, innovative concept which appears to have distinct possi-bilities is the use of organic liners which was first reported by Mirtskhulava et 'al. (1972). They reported that activities of certain anaerobes cause. a chemical reduction which results in accompanying increased dispersity' plasticity and a decreas·e in water permeability. Mirtskhulava, who has reported the U.S.S.R •. patented process, does not describe the necessary de tails such as suitability of materials, rFL tes of application, and associated experimental results. This paper will report some of the results from laboratory and field studies on control of seepage by the use of sodium carbonate, patented chemical called SS-13 and organic liners. · MATERIALS AND METHODS Laboratory Methods The soils that were used for test purposes consisted of subsoils of the Wood Mountain loam and Hatton sandy loam series that are known to seep. Soils used for analyses and test purposes were air-dried and passed through a 2-nnn sieve. Table 1 gives the soil textural character-is tics. Table 1. Soil Textural Characteristics % c % s % Si Wood Mountain silty loam - top soil 18 31 50 Wood Mountain clay loam - subsoil 40 25 35 Hatton fine sandy loam 10 79 11 . . Hydraulic conductivity tests were conducted using 3.2-cm diameter plastic· tubes, 30 em long. The bottoms of the tubes were equipped with a fine metallic screen that was covered with a fine layer of sand, 2 em thick (Fig. 1). A column of soil, 10 em in depth, was packed uniformly to a density of 1.3 g/cm3 with a mechanical packer (Jackson, 1962). A constant head of water of 15 em was maintained using a Mariette siphon. All· tests were replicated and are listed as follows: - 160 -Test 1 2 Control Method None Sodium carbonate 3 SS-13 4 Straw lined 5 6 7 8 9 10 Lined with straw and decayed material Lined with various types of straw Barley straw liner.in .soils of various textures Straw incorporated at various rates Incorporation with various types of straw Combination of gleiza-tion and other methods Field Studies Treatment Comparison of replicated checks. (a) Na2COg mixed in soil as per equation. (b) ~ amount of Na2COg as per equation. (c) ~ amount of Na2C03 as per equation. (d) Check (a) As per instruction (one part per thousand parts· water). (b) Check (a) Covered with top soil. (b) Covered with subsurface soil. (c) Check. (a) Straw line covered with subsoil. (b) Decayed material covered with subsoil. (c) Check. (a) 5 kg/m2 wheat straw (b) 5 kg/m2 oat straw (c) 5 kg/m2 barley straw (d) No treatment. 5 kg/m2 barley straw lined in soils of: (a) 10% C, 70% s, 20% Si (b) 14% C, 59% S, 27% Si (c) 18% C, 49% S., 33% Si (d) 21% C, 39% S, 21% Si {a) 15 kg/m2 wheat straw mixed with soil (b) 10 kg/m2 wheat straw mixed with soil (c) 5 kg/m2 wheat straw mixed with soil (d) Check (a) 5 kg/m2 wheat straw mixed with soil (b) 5 kg/m2 oat straw mixed with soil (c) 5 kg/m2 barley straw mixed with soil (d) Check (a) 5 kg/m2 wheat straw mixed with Na2co3 and soil. (b) 5 kg/m2 wheat straw covered with a mixture of soil and Na2co3• (c) 5 kg/m2 wheat straw covered with soil and a layer of bentonite. Several dugouts and ponds treated with sodium carbonate and with straw liners were observed over a two- to three-year period. Observa-tions consisted of observing the rate of drop of water surfaces for various treatment conditions. Prior to treatments, soils were sampled and analysed for texture and chemical parameters if the sodium carbonate method was used. - 161 -RESULTS AND DISCUSSION Laboratory An evaluation of the methodology by comparison of:replicates is given in F.ig. 2. It was found that the use of a soil packer built by Jackson (1962) res.ulted in reproducible results which was ·considered essential for the comparison of various methods of seepage control. The sodium carbonate method was evaluated (Fig• 3) and the results were comparable with those of Graveland (1973). The equation for determining the amount of sodium carbonate was considered acceptable for controlled laboratory conditions .• The use of SS-13 as per label instructions did not prove to be satisfactory (Fig. 4). In repeated trials, seepage rate was lower than the check only during the'initial stages of the test. ·For the Wood Mountain loam soil; the chemical did not prove satisfactory. Tests were not conducted onother types of textured soils. The use of straw as a lining material was evaluated (Fig. 5) following the rate recommended by Mirtskhulava et al. (1972). A test was·conducted to determine whether it was necessary to cover the straw liner with topsoil in order to enhance the gleization process. The test indicated. that the use of topsoil did not either enhance gleiza-tion nor impede the microbial process when compared to straw covered with subsoil. · · A test was conducted to determine whether decayed material such as straw or manure could be used as a lining material (Fig. 6). Results of the te.st indicated decayed material was equally acceptable as straw. The advantage of using decayed material as a liner wlls that the initial seepage rate wasgreatly reduced in comparison to that lined with straw. However, the time span for the decayecf material to cause seepage reduc-tion to an acceptable level was somewhat longer. Comparative tests were made to evaluate various types of straw material that might be used as liners. Wheat and barley straw were found to be equally acceptable as a source of lining material. The oat straw reduced seepage a level somewhat higher than· wheat and barley straw. Mirtskhulava (1972) reported that anaerobes cause a chemical . reduction of the clay particles in the soil. In a test to evaluate the lower limits of clay in which the process of gleization can be employed, it was found that gleization did occur.in soils containing clay contents as low as 10%. Seepage in the soil containing a clay content of 10% was reduced to an acceptable level by the gleization method. - 162 -Since straw liners might prove to be costly and difficult to install, the concept of incorporating straw into the soil was cons.Ldered. A test was designed in which rates of straw of 5 kg/m2 to 15 kg/m2 were mixed in with soil. Results of this test (Fig. 9) indicated that the seepage rate was reduced to a level of 1 cm/hr which is not considered to be acceptable for practical purposes. It is believed that a seepage of .1 c'm/hr .can be tole.rated in field situations. It was found that as the rate of straw was increased, the seepage rate or hydraulic con-ductivity was reduced. Following the same concept, a test was also· con-duc~ed in which 5 kg/m2 of wheat straw, oat straw and barley straw was incorporated into the soil. Similarly, it was found (Fig. 10) that a variation in soil materials did not reduce the hydraulic conductivity to a level of .1 cm/hr which was considered necessary. However, it was observed that oat straw did not reduce the seepage rate to the same level as wheat or barley straw when incorporated into soils. Because the gleization method of seepage control was very much a time-dependent process, a combination of gleization and use of sodium carbonate and use of bentonite was employed in a laboratory study (Fig. 11). In this manner, it was anticipated that bentonite or sodium carbonate would control seepage to an acceptable level until the process of gleization occurred within the soil. It was found that sodium car-bonate incorporated with. the soil which covered the straw layer or the use of bentonite over soil over straw was equally acceptable. A test conducted in which sodium carbonate was incorporated with straw and soil did not reduce the seepage rat.e to a level of 0.1 cm/hr that was deemed as a necessary minimum. Field Studies· Field trials of the sodium carbonate method of seepage control have been conducted by a number of farmers in Southwestern Saskatchewan. Effective control was achieved only in 35% of the reservoirs treated. It would appear that the treatment procedure must be strictly adhered to in order to ensure success. Another factor that·may have contributed to the failures was isolated pockets of sand i~ the reservoirs treated. However, reservoirs which did hold water after. the first season of use, continued to hold water after four years without an increase in the seepage rate. Based on a large number of soil analyses, an empirical relationship was.developed to determine the cation exchange capacity based on soil textural analyses for percent clay content. This ·equation, found to be generally applicable to a number of soils in Southwestern Saskatchewan is given as follows: CEC = 1.59 + 0.63 C ·where CEC = meq/100 g; and C =% clay content. - 163 ~ This empirical relationship should only be used if the chemical analyses of the soil to be treated with sodium carbonate are not readily avail-able. Only two reservoirs have been treated with organic liners -- one with straw and the second with decayed straw and barnyard manure. After two years, the seepage rate in these reservoirs had been reduced to an acceptable lev~l. Field inspection has indicated that gleization had occurred. A layer of blue-gray material beneath the organic layer had extended to a depth of 6 to 12 inches after a period of.two years. A number of reservoirs and·an irrigation canal have been lined with organic liners in 1976. These installations will also be monitored in the future. CONCLUSIONS The use of· sodium carbonate as a method of seepage control is considered acceptable. Based on field experiences, it appears that the treatment procedures must be strictly adhered to in order to ensure success. If the waters contained in the reservoirs treated with sodium carbonate are high in calcium and magnesium, the effectiveness of the treatment is expected to decrease with time. If.seepage reoccvrs, additional sodiumin the form of.sodium carbonate or sodium chloride may be added to improve seepage control. The microbiological gleization process of controlling seepage is considered to be most promising. Wheat straw, barley straw or decayed organic material is a preferred source of lining material. Rate of application of organic material of 4 kg/m2 is considered to be satis-factory. Laboratory .. studies have shown that incorporation of the organic material within the soil does not reduce the seepage rate to an acceptable level. A laboratory test with SS-13 as a method of controlling seepage has shown not to be effective on a Wood Mountain loam soil. Based on limited testing, it is believed that other methods such as the gleiza-tion method or sodium carbonate method are more acceptable. REFERENCES Graveland, B.N. and Olynyk, G. 1973. Laboratory tests on the use of sodium carbonate for reducing permeability in soil columns. CSAE 15(1): 12-14. Reginato, R.J., Meyers, L.E., and Ncikayama, Francis S. 1968. Sodium carbonate for reducing seepage from ponds. W.C.L. Report f/7, U.S. Water Conservation Laboratory, U.S • Department of Agricul-ture, Phoenix, Arizona 85040. Mirtskhulava, et al. 1972. Effect of microbiological process on perco-lation qf water through soil. pp. 713-721 In Fundamentals of Transport Phenomena in Porous Media. I.A.H.R.S. - I.S.S.S! Sympositnn,.University of Guelph. ,..... ... .c. ....... E u 4 >-~3 > ..,_ u :::> 0 z 0 u 2 u :::;j :::> <t a:: 0 >-:I: - 164 -____ "5l ___ ~ - Constant water level ----- Plexiglass cylinder Rubber stopper Drain tube Beaker Fig. 1. Schematic of apparatus for seepage studies. )( CHEGKNO.I o CHECK N0.2 0 100 200 300 400 500 600 700 800 900 1000 1100 1200 TIME(hrs) Fig. 2. Comparison of hydraulic conductivities of replicate check samples. 8 -7 ..c ' E 6 .... >-1-> 5 i= u :::> 0 4 ;z 0 u u 3 ::::i :::> <t a:: 0 2 >-:I: .180 ••o 040 ,.., .. o . II> 80 00 00 40 I 50 I" I I I .20 '\ ', 10, ............... ,.. 165 ,.. --- l Amount of NozC05 mixed with soil ~1 - NozC05mixed with soil as per e:quotion o---o No treatment . ........ _____ _ ----------·o 10 zo 50 40 s-o 60 10 eo wo 100 Time in hours Fig. 3. Hydraulic conductivities for various rates of application of sodium carbonate. 400 • CHECK x SS-13 800 1200 TIME (hrs) 1600 2000 Fig. 4~ · Seepage rates using the. SS-13 treatment. 2400 ,_ .... J::. ' E u >-t: 2: 1-u ::::> 8.5 8 7 6 0 5 ~ 0 v u ::J ::::> <l a: 0 ·>-::c 4 3 2 0 200 400 600 800 166 .. x CHECK 0 STRAW LAYER COVERED WITH SUBSURFACE A STRAW LAYER COVERED WITH TOPSOIL X----x t. 1000 1200 1400 1600 1800 2 . 000 2200 2400 TIME ( hrs) Fig. 5. Effect of topsoil on the gleization method of seepage control. 28 26 24 22 ~ ! 20 ,. ... ~ 18 t; g , 8 IG " :::; ~ 14 .. ~ 12 10 x CHECK o WHEAT STRAW LINING 6. DECAYED MATERIAL LINING 0~--~-·~-· ~·~==-~~==~ 10 100 1000 10000 TIME {hrs) Fig. 6. Decayed material compared to straw as an organic liner for seepage control. 24 20 16 .s::; ' E 12 0 >- 8 1-> i= u ;:) 0 z 0 u u ::i ;:) ~ a:: 0 >-3 :I: 2 Fig. 7. "'i:'3 .s::. ....... E u >-..... > i= U2 ::> 0 z 0 u u ....J ::> <t 0: 0 >-J: 0 - 167 -6 CHECK o BARLEY STRAW LINED • WHEAT STRAW LINED x OAT STRAW LINED 1200 TIME (hrs) 1600, 2000 2400 Comparison of wheat, oat and barley organic liner for seepage control. • 10% CLAY x 14%CLAY o 16% CLAY ll 21% CLAY straw as an 600 600 1000 1200 1400 1600 TIME (hrs) Fig. 8. Effect of clay composition on the gleization method of seepage control. .E 28 ' E u ._, >- 24 t: > E2o :::> 0 z 8 16 ~ _J ~ 12 a:: 0 >-:I: 8 4 0 200 400 168 t. CHECK • STRAW MIXED AT 15 kg /m o STRAW MIXED AT IOkg/m x STRAW MIXED AT 5 kg/ m t.-t.-t.--l!r--t..-----·-i 600 800 1000 1200 1400 1600 1800 2000 2200 TIME ( hrs) Fig. 9. Effect of rates of straw incorporated with soil on seepage control. .... 30. 28 26 24 .s:::. 22 ' E 2o 3 18 >- 16 f- 14 ~ 12 f-0 :::> Cl z 0 0 7 0 :::J 6 :::> <( a: 5 Cl >-I 4 A CHECK 0 BARLEY STRAW INCORPORATED • WHEAT STRAW INCORPORATED x OAT STRAW ~CORPORATED 800 1200 1600 2000 TIME (hrs) 2400 Fig. 10. Effect of wheat, oat and barley straw when mixed with soil on seepage control. .... ..r::. ....... 24 E20 >-1-> 16 1-u g 12 z 0 u 4 u ..J :::> <[ 0:: 0 >-:I: 2 - 169 -x CHECK A STRAW LINED WITH Na2C03MIXED WITH TOP SOIL o STRAW LINED WITH BENTONITE TREATED TOP SOIL o STRAW MIXED WITH Na2C03 AND WITH TOP SOIL ·------~-------------------------x~----------x--~-----x Fig. 11. Gleization method combined with sodium carbonate and bentonite method of seepage control. 

Seepage control in farm-sized dugouts

eCommons@USASK

https://harvest.usask.ca/bitstream/10388/11194/1/W.%20Nicholaichuk%2c%201977.pdf

Seepage control in farm-sized dugouts

Abstract

Similar works

Full text

Available Versions

University of Saskatchewan Research Archive

eCommons@USASK