Natural food colorants are usually used in concentrated form. Production of concentrate including enzymes, temperature, clarifying agents and mechanical operation may have significant influence on valuable components of the end product. In our study, we investigated the effects of two different pectolytic enzyme preparations (Fructozym P and Pectinex BE XXL) and five clarifying agents (three bentonites and two silica sols) on total polyphenol, total anthocyanin content and colour parameters of Haschberg and Samocco elderberry juices. Our results showed that enzymes and clarifying agents applied during juice production influenced the investigated quality parameters of both varieties. Generally, in case of Samocco variety Fructozym P with bentonites, while in case of Haschberg Pectinex BE XXL with silica sols proved the most effective combinations to reach high quality values. This fact should be considered in case of industrial application

Nagy, Eszter

Stéger-Máté, Mónika

Szalóki-Dorkó, Lilla

Szalóki-Dorkó Lilla

Nagy Eszter

Stéger-Máté Mónika

University of Szeged

Volume 60(1):71-76, 2016Acta Biologica Szegediensishttp://www2.sci.u-szeged.hu/ABSARTICLE1Department of Technology and Food Chain Analysis, NARIC Food Science Research Institute, Hungary2Department of Food Preservation, Faculty of Food Science, Szent István University, HungaryEffect of enzymes and clarifying agents on quality parameters of elderberry juiceLilla Szalóki-Dorkó1,2*, Eszter Nagy2, Mónika Stéger-Máté2ABSTRACT                        Natural food colorants are usually used in concentrated form. Production of concentrate including enzymes, temperature, clarifying agents and mechanical operation may have significant influence on valuable components of the end product. In our study, we investi-gated the effects of two different pectolytic enzyme preparations (Fructozym P and Pectinex BE XXL) and five clarifying agents (three bentonites and two silica sols) on total polyphenol, total anthocyanin content and colour parameters of Haschberg and Samocco elderberry juices. Our results showed that enzymes and clarifying agents applied during juice production influenced the investigated quality parameters of both varieties. Generally, in case of Samocco variety Fructozym P with bentonites, while in case of Haschberg Pectinex BE XXL with silica sols proved the most effective combinations to reach high quality values. This fact should be considered in case of industrial application. Acta Biol Szeged 60(1):71-76 (2016)KEy WoRdSanthocyaninclarificationcolourelderberrytechnologySubmitted May 1, 2016; Accepted Sept 18, 2016*Corresponding author. E-mail: l.szaloki-dorko@cfri.hu71IntroductionIn the food industry, natural or synthetic food colorants are used to improve, restore or establish the colour of the final product. The regulation of the European Commission 1333/2008/EC states that food containing certain artificial colouring material, must be labelled with the following phrase: „may have an adverse effect on activity and attention in children” (OJEU 2008). For this reason, food colorants from natural sources are becoming preferred as alternatives of synthetic food agents to adjust food colour.Natural food colorants are usually used in concentrated form in the food industry. However, various physical and biological factors such as temperature, enzymes, heat and me-chanical stress may have influence on the quality parameters of the end product (Stéger-Máté et al. 2006; Szalóki-Dorkó et al. 2014).Many studies investigated the effect of processing tech-nology on valuable compounds in fruit juice. Heat treat-ment caused degradation of anthocyanin content, (Bakker and Pildre 1992; Wesche-Ebeling and Argaiz-Jamet 2002; Bakowska-Barczak et al. 2003; Garzon and Wrolstad 2003; Talcott et al. 2003; Kirca et al. 2007; Patras et al. 2010; Sui 2014; Szalóki-Dorkó et al. 2015) pH reduction and storage temperature influenced also the colour stability of straw-berry nectar (Gössinger et al. 2009). In case of red cabbage anthocyanin composition and content were changed during fermentation, storage and stewing (Wiczkowski et al. 2015). Total polyphenol and total pigment content of Rubus coreanus Miquel fruit were degraded during jam processing (Lee et al. 2013). Effects of clarification and pasteurisation on anthocya-nins and the colour parameters of pomegranate juice were also investigated (Turfan et al. 2011; Vegara et al. 2013; Valero et al. 2014) and found that clarifying agents, such as bentonites or gelatines improve the colour, flavour and physical stability of the treated juice (Turfan et al. 2011).Anthocyanin colorants are suitable for food colouration with a low pH level such as soft drinks, water ice-cream, dairy products, table jellies, because of the molecules are stable in acidic medium (Cooper-Driver 2001; Bakowska-Barczak et al. 2003; Valero et al. 2014). Elderberry (Sambucus nigra L.) may be suitable colouring material in food industry, because of the high pigment content (Seruga et al. 2007; Lee and Finn 2007; Veberic et al. 2009). Elderberry anthocyanins are almost exclusively cyanidin-glycosides, from which cyanidin-3-glucoside and cyanidin-3-sambubioside were detected as the most abundant compounds (Veberic et al. 2009). Accord-ing to a previous study, cyanidin-3-sambubioside was the most stable pigment molecule against processing technology (Drdak and Daucik 1990). However, the effect of enzyme and clarifying agents on valuable compounds of elderberry during processing is a less researched area.72Szalóki-Dorkó et al.The aim of this research was to investigate the effects of enzyme preparations and clarifying agents on some quality parameters of elderberry juices. Total polyphenol, total an-thocyanin content and colour parameters were investigated in elderberry juices made from two varieties. Further aim was to determine the suitable combination of applied enzymes and clarification agents to reach higher quality values.Materials and MethodsTwo different elderberry (Sambucus nigra L. sbsp. nigra) va-rieties, namely Haschberg (Austrian) and Samocco (Danish) were harvested from the growing area of Vál of the Hungarian Elderberry Grower Cooperative, Hungary in 2013. During the experiment, two type of enzyme preparations were used (Table 1): Pectinex BE XXL and Fructozym P (Kerttrade Ltd., Dunavarsány, Hungary). Furthermore, three type of bentonite clarifying agents were applied (Erbslöh, Germany): SodiBent Supra is a natural finely milled sodium powder to clarify wine, fruit juice and vinegar. GranuBent PORE-TEC is a natural sodium bentonite granulated by PORE-TEC technology, using in clarification of wine, fruit juice and vinegar. NaCalit PORE-TEC contain-ing premium quality granulated sodium-calcium bentonite to clarify wine. In additional, two types of silica sols (Erbslöh, Germany), namely Klar-Sol 30 (alkaline) and Klar-Sol Super (acid) were investigated.Preparation and measurementsElderberry juices were prepared according to industrial pro-tocols under laboratory conditions (Fig. 1).Total anthocyanin concentration was determined by the method of Lee et al. (2005). Results were calculated by the following equation and were expressed in mg cyanidin-3-glucoside equivalents (CGE) per L of elderberry samples: (A x MW x D x 103)/(ε x l)where A = (A520nm-A700nm) pH1-( A520nm-A700nm) pH 4.5; MW is the molecular weight of cyanidin-3-glucoside (449.2 g/mol); D = dilution; 103 = factor for conversion from g to mg; ε = molecular extinction coefficient for cyanidin-3-glucoside (26 900 L/(mol x cm) and l is the path length (cm).Total polyphenol content was determined according to the method of Singleton and Rossi (1965) and values were expressed in mg gallic acid equivalent (GAE) per L.Colour parameters were measured by digital colorimeter (Konica Minolta CR 410) and L* (lightness factor), a* (green-red) and b* (yellow-blue) values were recorded. Colour difference (ΔE*) was calculated from a*, b* and L* values according to the following equation and data were evaluated compared to the control samples according to Table 2.ΔE* = (Δa*2 + Δb*2 + ΔL*2)1/2Statistical analysisT-test was used (SPSS 13.0 version) to analyze the signifi-Pectinex BE XXL Fructozym POrigin Aspergillus nigerAspergillus nigerActivity pectin-lyase pectin-esterase, pectin-lyase, endo-polygalac-turonasepH optimum pH 4.5 <pH 3.0Temperature optimum 50-55 °C 20-55 °CTable 1. Parameters of applied enzyme preparations. Figure 1. Production scheme of elderberry juice processing.73Quality parameters in elderberry juicecance of anthocyanin and polyphenol contents changes com-pared to the control sample. The difference was considered significant when P<0.05.Results and discussionThe sample No. 0 was considered as control sample, which was treated by enzyme, but not by clarifying agent. For sim-plicity, treatments with clarifying agents were indicated as No. 1-5, as shown in Table 3.Total polyphenol contentFigure 2 illustrates total polyphenol content of the Hasch-berg juices. The Fructozym P with SodiBent Supra (1) and GranuBent PORE-TEC (2) combination resulted the highest polyphenol content (10 083 ± 473 mg/L and 10 080 ± 287 mg/L), while Klar-Sol 30 + Erbigel (4) combination the low-est (7805 ± 226 mg/L).In case of Pectinex BE XXL enzyme-treated juices, NaCalit PORE-TEC (3) clarifying agent caused the highest polyphenol concentration (10 139 ± 83 mg/L). The lowest polyphenol content was measured in case of Pectinex BE XXL enzyme and Klar-Sol Super - ErbiGel (5) combination (7944 ± 212 mg/L). This result is reduced by 20% com-pared to sample No. 0. Considering the two applied enzyme preparations, values of bentonite-treated juices were higher compared to the silica sol-treated juices.Figure 3 shows total polyphenol content of Samocco variety juices. Fructozym P and SodiBent Supra (1) com-bination resulted the highest polyhenolic value in Samocco juice (21 833 ± 629 mg/L), which is 17% higher than the control sample. The lowest polyphenol content (19 722 ± 1052 mg/L) was measured in case of Fructozym P enzyme treated control sample.Among the Pectinex BE XXL treated elderberry juices, SodiBent Supra (1) and NaCalit PORE-TEC (3) proved to be the most effective clarifying agents. These clarifying agents resulted the highest total polyphenol concentration (19 750 ± 173 mg/L and 19 778 ± 798 mg/L). The applied Klar-Sol 30 + ErbiGel (4) caused the lowest value (19 250 ± 822 mg/L), although the difference was not considerable (3%).Generally, the applied clarifying agents combined with Fructozym P enzyme resulted higher total polyphenol content compared to the Pectinex BE XXL-treated and initial samples in case of Samocco juices.ΔE* Visible differenceΔE*≤0.5 non-visible0.5<ΔE*≤1.5 less visible1,5<ΔE*≤3.0 visible3.0<ΔE*≤6.0 obvious6.0<ΔE* very obviousTable 2. Evaluating of colour difference (ΔE*).Figure 2. Total polyphenol content of Haschberg juice treated by several enzymes and clarifying agents. * represents significant differ-ences (P<0.05) in total polyphenol content compared to the untreated control sample.Figure 3. Total polyphenol content of Samocco elderberry juice treated by different enzymes and clarifying agents. * represents significant differences (P<0.05) in total polyphenol content compared to the untreated control sample.Identification number Applied clarifying agents1 SodiBent Supra2 GranuBent PORE-TEC3 NaCalit PORE-TEC4 Klar-Sol 30 + ErbiGel5 Klar-Sol Super + ErbiGelTable 3. Identification numbers of the applied clarifying agents.74Szalóki-Dorkó et al.Total anthocyanin contentTotal anthocyanin content of Haschberg samples is illustrated in Figure 4. Pectinex BE XXL-treated juices had higher total pigment concentration than Fructozym P-treated samples. Among the clarifying agents, SodiBent Supra (1) provided the highest anthocyanin yield (5728 ± 511 mg/L), which is 15% higher; while the lowest anthocyanin content was measured in sample (5) (Klar-Sol Super + ErbiGel), which is 29% lower compared to the initial Pectinex BE XXL sample.In case of Fructozym P-treated elderberry juice, the low-est anthocyanin content was measured (3384 ± 54 mg/L) in Klar-Sol Super + ErbiGel-treated sample (5), which is 31% lower than the control juice (4798 ± 685 mg/L). As regard the enzyme and clarifying agent combination, total anthocyanin content increased in case of bentonite treated juices, while silica sols combining with gelatine, resulted reduction in pigments content compared to the untreated samples. This result is consistent with a Turkish study, which was described about black carrot juice (Valero et al. 2014). This fact should be considered in case of industrial application.The results of Samocco juices (Fig. 5) showed that Fruc-tozym P enzyme was more efficient to reach higher pigment content than Pectinex BE XXL enzyme preparation. This observation is controversial to the results obtained by Hasch-berg juices, which may explained by the different enzyme composition and variety characteristic. Among the applied Fructozym P enzyme-treated juices, Klar-Sol Super + ErbiGel combination (5) proved the highest total anthocyanin value (7971 ± 848 mg/L), in this case pigment yield increased by 35% relative to the control sample. Klar-Sol 30 + ErbiGel combination (4) resulted in the lowest pigment content (5611 ± 998 mg/L) of Samocco juices.Among the Pectinex BE XXL enzyme-treated juices, sample 2 (GranuBent PORE-TEC) had the highest total an-thocyanin content (6245 ± 489 mg/L), which is 12% higher value than the control sample. The juice that contained the lowest anthocyanin content was treated by Pectinex BE XXL enzyme and SodiBent Supra (1) clarifying agent combination (4614 ± 285 mg/L).Colour parametersColour differences (ΔE*) varied during the experiment (Table 4). ΔE* values were under the level of 0.5, so no vi-sible difference was observed after SodiBent Supra (1) and GranuBent PORE-TEC (2) treatments in case of Pectinex BE XXL in Haschberg elderberry juices. In most cases NaCalit PORE-TEC (3) and Klar-Sol 30 + ErbiGel (4) clarifying agents caused less visible difference, while obvious visible colour difference was detected after using Klar-Sol Super + ErbiGel (5) in both varieties. Generally, colour difference can be observed in enzyme-treated elderberry juices, if they are combined by bentonite and silica sol clarifying agents.Figure 4. Total anthocyanin content of Haschberg elderberry juice treated by different enzymes and clarifying agents. *represents sig-nificant differences (P<0.05) in total anthocyanin content compared to the untreated control sample.Figure 5. Total anthocyanin content of Samocco elderberry juice treated by several enzymes and clarifying agents.*represents signifi-cant differences (P<0.05) in total anthocyanin content compared to the untreated control sample.Clarifying agent 1 2 3 4 5Haschberg - - - - -ΔE* Fructozym P 1.32 2.71 0.90 2.49 3.78ΔE* Pectinex BE XXL 0.40 0.20 0.81 0.65 3.06Samocco - - - - -ΔE* Fructozym P 3.64 0.73 2.02 0.52 2.52ΔE* Pectinex BE XXL 1.76 4.10 0.53 0.53 3.69Table 4. Colour difference (ΔE*) values of the treated elderberry juices.75Quality parameters in elderberry juiceConclusionThis study showed that applied enzyme preparations and clarifying agents influenced the investigated quality param-eters of both varieties during juice production. Generally, in case of Samocco variety Fructozym P with bentonites, while in case of Haschberg juices Pectinex BE XXL with silica sols proved to be the most effective combinations to reach high quality values. This phenomenon is probably variety dependent characteristic due to different phenolic composi-tion, which should take into account in case of industrial application. Therefore, it would be worthwhile to investigate the structure of anthocyanidin-saccharides of elderberry juice that may influence the effectiveness of enzymatic treatment and clarification. Summary, the application of enzymes and clarification agents during technology can influence the colour parameters of the final elderberry product.ReferencesBakker J, Bridle P (1992) Strawberry juice color: The effect of sulphur dioxide and EDTA on the stability of antho-cyanins. J Sci Food Agric 60:477-481.Bakowska-Barczak A, Kucharska AZ, Oszmianski J (2003) The effects of heating, UV irradiation and storage on stability of the anthocyanin - polyphenol copigment complex. Food Chem 81:49-355.Bridle P, Timberlake CF (1997) Anthocyanins as natural food colours - selected aspects. Food Chem 58:103-109.Cooper-Driver GA (2001) Contributions of Jeffrey Harborne and co-workers to the study of anthocyanins. Phytochem 56:229-236.Drdak M, Daucik P (1990) Changes of elderbery (Sambucus nigra) pigments during the production of pigment con-centrates. Acta Aliment 19:3-7.Garzon GA, Wrolstad RE (2002) Comparison of the stability of pelargonidin-based anthocyanins in strawberry juice and concentrate. J Food Sci 67:1288-1299.Gössinger M, Moritz M, Hermes M, Wendelin S, Scherbichler H, Halbwirth H, Stich K, Berghofer K (2009) Effects of processing parameters on colour stability of strawberry nectar from puree. J Food Eng 90:171-178.Kirca A, Ozkan M, Cemeroglu B (2007) Effects of tempera-ture, solid content and pH on the stability of black carrot anthocyanins. Food Chem 101:212-218.Lee DJ, Lee H, Lee S, Lee CY, Kim D (2013) Effects of jam processing on anthocyanins an antioxidant capacities of Rubus coreanus. Food Sci Biotechnol 22:1607-1612.Lee J, Durst RW, Wrolstad RE (2005) Total monomeric an-thocyanin pigment content of fruit juices, beverages, natu-ral colorants, and wines by the pH differential method: Collaborative Study, J AOAC Int 88:1269-1278.Lee J, Finn CE (2007) Anthocyanins and other polypheno-lics in American elderberry (Sambucus canadensis) and European elderberry (S. nigra) cultivars. J Sci Food Agric 87:2665-2675.Official Journal of the European Union, List of the food colours referred to in Article 24 for which the labelling of food shall include additional information, Annex V., 31.12.2008.Patras A, Brunton NP, O’Donnell C, Triwari BK (2010) Effect of thermal processing on anthocyanin stability in food; mechanism and kinetics of degradation. Trends Food Sci Technol 21:3-11.Seruga LM, Medvidovic-Kosanovic M, Nova I (2007) Antho-cyanin content and antioxidant activity of various red fruit juices. Deutsche Lebensmittel - Rundschau 103:58-64.Stéger-Máté M, Horváth D, Barta J (2006) Investigation of colourant content and stability in elderberry (Sambucus Nigra L.). Acta Aliment 35:117-126.Sui X, Dong X, Zhou W (2014) Combined effect of pH and high temperature on the stability and antioxidant capac-ity of two anthocyanins in aqueous solution. Food Chem 163:163-170.Szalóki-Dorkó L, Légrádi F, Abrankó L, Stéger-Máté M (2014) Effects of food processing technology on valuable compounds in elderberry (Sambucus nigra L.) varieties. Acta Biol Szeged 58:45-48.Szalóki-Dorkó L, Stéger-Máté M, Abrankó L (2016) Ef-fects of fruit juice concentrate production on individual anthocyanin species in elderberry. Int J Food Sci Technol 51:641-648.Talcott ST, Brenes CH, Pires DM, Del Pozo-Insfran M (2003) Phytochemical stability and colour retention of copig-mented and processed muscadine grape juice. J Agric Food Chem 51:957-963.Turfan Ö, Türkyilmaz M, Yemis O, Özkan M (2011) Antho-cyanin and colour changes during processing of pome-granate (Punica granatum L., cv. Hicaznar) juice from sacs and whole fruit. Food Chem 129:1644-1651.Valero M, Vegara S, Martí N, Mena P, Saura D (2014) Clari-fication of pomegranate juice at industrial scale. J Food Process Technol 5:324.Veberic R, Jakopic J, Stampar F, Schmitzer V (2009) Eu-ropean elderberry (Sambucus nigra L.) rich in sugars, organic acids, anthocyanins and selected polyphenols. Food Chem 114:511-515.Vegara S, Martí N, Mena P, Saura D, Valero M (2013) Ef-fect of pasteurization process and storage on color and shelf-life of pomegranate juices. LWT - Food Sci Technol 54:592-596.76Szalóki-Dorkó et al.Wesche-Ebeling P, Argaiz-Jamet A (2002) Stabilization mechanisms for anthocyanin: the case for copolymer-ization reactions. In Barbosa-Cánovas J, Aguilera GV, Welti-Chanes JM eds. Engineering and Food for the 21th Century. CRC Press, Boca Raton.Wiczkowski W, Szawara-Nowak D, Topolska J (2015) Chang-es in the content and composition of anthocyanins in red cabbage and its antioxidant capacity during fermentation, storage, stewing. Food Chem 167:115-123.

Effect of enzymes and clarifying agents on quality

parameters of elderberry juice

http://acta.bibl.u-szeged.hu/46267/1/6071.pdf

Effect of enzymes and clarifying agents on quality parameters of elderberry juice

Abstract

Similar works

Full text

Available Versions

University of Szeged