Jones, Winston William

English

ScholarSpace at University of Hawai'i at Manoa

DIV l SI UN OF E NT ()MOLOG Y. EOAF.D OF AGR I CULT URE AUD FOR.ES TR'i HONOLULU , H ,i lJ1-i. I I HAWAII AGRICULTURAL EXPERIMENT STATION of the UNIVERSI'fY OF HAWAll CIRCULAR No. 17 METHYL-BROMIDE FUMIGATION OF PAPAYA AND TOMATO by WINSTON W. JoNI~S, Assistant Horticulturist H ONOLULU, T. H. August 1940 HAWAII AGRICULTURAL EXPERIMENT STATION of the UNIVERSITY OF HAWAII D. L. CRAWFORD, President University of Hawaii J. H. BEAUMONT, Director Hawaii Agricultural Experiment Station CONTENTS Page Introduction --------------- --- ---- ----- -- ---- -- --- --------------------- -- --- -- ---- ···· ···· ···--·· ··· 5 Nature of Methyl Bromide ... ___ . -· ---- ·--- · -- ------·- -·······- ·· -····· ···· ··- ---· 5 Experimental Results ········ ····· ·· ---- - ----- -·--------·---···-· ·- - -····· -··· -····- --- ---· 6 Papaya ·------------- ···- ··- ·-- ···· ····· ·-- ·--------- ·-····------ ----·---··· ··· ····· ···------··· 6 ----- -- ---------- --- · -· · ······· ·· ------------ --------------·-··· ···· ---------- ·· · ·· ·------ 9 Discussion ------- --· ------ -·-- ·········· --- ·- ·---------------· ····· -----·-·· ---- ···-········ ·· ---- ·· 10 Tomato Application of Methyl Bromide ____________ ·-·· -------- ····· ········· ······ ------ 10 lV[ethyl-Bromide Versus Vapor-Heat Sterilization............ ___ ····· 11 Summary ----------··- ---- -·- -····· -·· ··· ·· ·--------·------- ·---·--------····- ·· ·-···· ·· ··· ·· --· ·---· 12 Papaya ·-----·- ----- ----- ······ ·· ···-··· ··--------·-- ·-----·--··------- -· ···· ·· ···· -···· ·· ·----·· 12 T01nato ------ ·-- ·---- -- -····· ··· ··· -· ··· ···· -- --- ···--------------·-- ·· ··- -- ···· ··········· ------ 13 Recommendations 13 Papaya ----·--- ---------- ············· ···- -- ------·---- ·---· ·- ------ -·-- ··········· ··· ····-- ---- 13 Tomato ------·--·----- ·-·-··· ·- ·· ······ ·· -----------···----------- · ·--· ······· ····· ···· ·· ··----- 13 Literature Cited -------- ---·· ·· ···· --- ·- -··- --------------------·--··-· -·- ·- ···· ·· ····· -··· ------- 14 Acknowledgment The author and the director wish to express their appreciation to Mr. 0. C. McBride, of the Bureau of Entomology and Plant Quaran­tine, United States Department of Agriculture, for his cooperation in supplying the methyl bromide and furnishing the equipment for the experimental work discussed herein. Earlier work (not here reported) was done in cooperation with Mr. L. A. Whitney, of the Territorial Plant Inspection Office. INTRODUCTION Since November 1, 1938, Hawaiian-grown fruits and vegetables have had the right of entry to mainland United States, provided they had undergone one of two treatments, designed to destroy the Medi­terranean fruitfly and the melonfly and approved by the U. S. Bureau of Entomology and Plant Quarantine. One, a cold treatment, has been found to produce a "chilling" effect on most tropical fruits ; it is, therefore, not considered practical in Hawaii. The second, known as the vapor-heat treatment, has been tested experimentally and applied to all commercial shipments of Hawaiian fruits and vegetables previously barred from the mainland. Vapor­heat sterilization has been discussed more fully in Circulars 14 and 16, issued by this station (2, 3) . 1 Effective as of August 1, 1940, a third method of sterilization has been approved for specific Hawaiian agricultural crops, namely: papaya, guava, bell pepper, bitter melon, cucumber, summer squash, string bean, and tomato. The method consists of fumigation, with methyl bromide, 2 pounds per 1,000 cubic feet, for 30 hours at atmos­pheric pressure and at a temperature not less than 80° F. The experiment station has been studying methyl-bromide fumi­gation for several years, and it is the purpose of this circular to present the available information which may be of value to prospective shippers. It must be remembered, however, that only laboratory experimentation has been possible heretofore. Experimental ship­ments, which are planned for the near future, may bring to light new factors and lead to changes in recommendations. NATURE OF METHYL BROMIDE Methyl bromide is a poisonous gas and should be handled as such. It is colorless and practically odorless in concentrations used for fumi­gation. Any operator working with the gas should use an approved gas mask. This is a relatively new gas in the field of fumigation. Although the efficiency of methyl bromide as a fumigant has been tested, there 1 Reference is made by number ( it alic) to Literature Cited. p. 14. 6 Circular 17, Hawaii Experiment Station has been relatively little study of the physiological effects of the gas on plants. In general, plants are more tolerant to methyl bromide than to certain other fumigants-hydrocyanic acid or carbon tetrachloride. Mackie ( 4) found that green beans, bell peppers, tomatoes, and other fruits were uninjured by treatment at the rate of 20 pounds of methyl bromide per 1,000 cubic feet for 10 hours, under a 20- to 27-inch vacuum. Coloring was slightly delayed in tomatoes. EXPERIMENTAL RESULTS Of the crops included in the authorization for methyl-bromide fumigation, papayas and tomatoes are of chief commercial importance locally at present, and physiological studies have been made on the effect of fumigation on these two fruits at various stages of maturity. Data were obtained on color development, absorption of methyl bro­mide, and holding qualities after treatment. Unless otherwise speci­fied, all experimental fruits were treated for 30 hours with methyl bromide at the rate of 2 pounds per 1,000 cubic feet . PAPAYA Color Development. The most obvious effect of methyl bromide on the papaya is a retardation in coloring. This effect varies with the maturity of the fruit at the time of treatment and with the dosage and length of treatment. Mature-green fruits are affected more than firm­ripe fruits. The color of the ripe fruits is fully established before treatment and does not change. Papayas treated with 2 pounds of methyl bromide and held at room temperature ripened 3 to 4 days later than untreated fruits. When held in cold storage ( 50° F.) for 6 days, check and treated fruits varied by only 2 to 3 days in ripening. Greater loss from decay occurred in the treated fruit, a factor which will be discussed more fully later. Coloring, as well as catalase activity in the papaya, is an index of ripening. That methyl bromide retards coloring has been pointed out. As a further indication that retardation of the ripening process does occur, table 1 shows the effect of methyl bromide on catalase activity. 7 M ethyl-Broniide Fumigatio•, Table 1.-Effect of methyl bromide on catalase activity in papayas treated firm ripe and held until ripe ( each figure average of 3 fruits) Lot Check lot, held at room temperature Methyl-bromide-treated fruits, held at room temperature Check lot, held at soc F. for 5 days, then at room temperature for 2 days Methyl-bromide-treated fruits, held at soc F. for 5 days, then at room tern-perature for 2 days Imme-diately before treatment 16.7 14.4 12.5 12.8 Imme-diately after treatment 4.4 Catalase activity 24 hours after treatment ----15.4 48 hours after treatment 11.7 5 days after treatment 7 days after treatment 1.6 1.6 8.4 5.8 3.1 2.5 Absorption of Methyl Brmnide. If fumigation is to be effective against the Mediterranean fruitfly and the melonfly, it is necessary for the bromide to penetrate the fruit. This it does, as shown in table 2. Table 2.-Absorption and retention of methyl bromide by papayas treated firm­ripe and held until ripe ( composite sample of 3 fruits from lot of 24) Time of analysis Immediately after treatment After 3 days at room temperature After 5 days at Soc F. plus 3 days at room temperature Methyl bromide1 per kilogram of fruit M£Uigram.s 27.2 27.0 14.2 Loss in methyl bromide Percent 0.7 47.8 1 Bromide determined, then expressed as methyl bromide. 8 Circular 17, Hawaii Experiment Station Holding Qualit-ies. The chief causes of loss in papayas between time of harvesting and marketing are decay organisms. Normally such organisms do not develop until the fruit is slightly overripe, clue to a natural resistance of papaya, but treatment with methyl bromide causes a premature loss of resistance with a consequent reduction in holding qualities . This premature loss of resistance to infections by tropical fruits , clue to chill in cold storage and certain chemical treat­ments, has been pointed out by Wardlaw et al. ( 5). Among the organisms which reduce the storage period for papayas are included wound parasites, such as Rhizopus and Penicillium spe­cies, which enter the fruit through breaks in the skin. More serious because less avoidable are such organisms as Colle­totrichum and Phytophthora, which cause latent infections in uninjured fruits. Infection may occur at any time during development, remain­ing dormant until the fruit has ripened or until environmental condi­tions within the fruit are favorable. That decay losses are more senous m methyl-bromide-treated fruits may be seen from table 3. Table 3.-Relation of methyl bromide to decay in papayas treated firm-ripe and held until ripe Number Percentage Number of of fruits of f ruits I,ot fruits showing showing treated decay decay Check lot, held at room temperature for 4 days 19 163 Methyl-bromide-treated fruits, held at room temperature for 4 days (fruits treated for only 2 hours) 17 7 41 Check lot, held for 6 days at 50° F ., plus 2Y, days at room temperature 12 Methyl-bromide-treated fruits, held for 6 days at 50° F., plus 2Y, days at room temperature 12 678 Anthracnose [C olletotrichum sp. (gloeosporioides ?) ] is the chief cause of loss in papayas treated with methyl bromide ( see fig. 1). Cold storage retards the development of the organisms, but mature­green or firm-ripe fruits must be held at room temperature for several 8 9 .Alethyl-Bromide Fumigation days after cold storage in order to ripen. It is during thi s ripening period that anthracnose develops most rapidly on treated fruits. Figure 1.-Papayas harvested firm-ripe, held in storage at 50° F. fo r 6 clays, then allowed to ripen for 2 clays at room temperature: Fruit at lef t from check lot; fruit at right treated with methyl bromide. Note spots on trea ted fruit indicating decay clue to anthracnose. TOMATO Color Development. In tomatoes as well as papayas, fumigation with methyl bromide causes a marked retardation in coloring. This delay amounts to 3 to 4 clays for "pinks" and 4 to 6 clays for mature­green fruits held at room temperature. ·when tomatoes were placed in cold storage ( 50° F. ) immediately after treatment and held for 6 clays, 6 additional days at room tem­perature were required for the pink fruits to ripen , while some of the mature-green fruits decayed without ripening. 10 Circular 17, Hawaii Experiment Station Absorption of Methyl Bromide. A small quantity of methyl bro­mide is absorbed and retained by tomatoes, as may be seen from table 4. This residue could not be detected by taste, since the flavor of tomatoes is less delicate than that of papayas. Table 4.-Absorption and retention of methyl bromide by tomatoes treated pink and held until ripe (composite sample of 6 fruits from lot of 42) Time of analysis Immediately after treatment After 4 days at room temperature After 7 days at 50° F., plus 4 days at room temperature Methyl bromidel per kilogram of fruit Milligrams 32.8 26.1 22.8 Loss in methyl bromide Percent 20 30 1 Bromide determined, then calculated as methyl bromide. Holding Qualities. Tomatoes are far less subject than the papaya to latent infections, and the period of 3 to 6 days at room temperature required for ripening is not a serious handicap. With this fruit, according to Baker (1), most serious loss is due to wound parasites. To date experimental results have not indicated that methyl-bromide fumigation seriously increases this loss. It is, however, of utmost importance to the shipper that only fruits free from mechanical damage, growth cracks, blossom end rot, and insect injuries be treated. Since cold storage delays the ripening time of tomatoes, mature­green fruits should be held at room temperature after treatment, until pink, and then placed in cold storage at a temperature of 50° to 60° F. DISCUSSION APPLICATION OF METHYL BROMIDE Methods of applying methyl bromide (bromomethane) are under the supervision of the U. S. Bureau of Entomology and Plant Quar­antine and must meet the approval of the Federal inspector. However, certain general requirements justify discussion. 11 Methyl-Bromide Fumigation First, the operator must provide a suitable fumigation chamber. It should be metal-lined, and all openings for ventilation and entrance must be so constructed that the chamber, when closed, will be gas­tight at atmospheric pressure. If the same chamber is to be used for methyl-bromide fumigation as for vapor-heat sterilization, provisions should be made for sealing the vapor-heat mixing chamber. The room must be equipped with a fan capable of circulating the air at least once every 3 minutes; otherwise the methyl bromide, being about 33,'i times as heavy as air, would tend to stratify. Heat must be provided to attain the specified temperature of 80° F. after the room is loaded (not more than 4 hours should be neces­sary). In a closed room of this type one or more electric light bulbs should supply sufficient heat. The bulbs should be connected to a ther­mostat, to maintain the proper temperature. An exposed-wire electric heater cannot be used. In estimating the dosage of methyl bromide (2 pounds per 1,000 cubic feet) , the space occupied by the material to be fumigated must be included . The gas should be discharged into the room immediately in front of the fan, to be diluted with air instantly. Severe injury occurs when liquid methyl bromide comes in contact with the fruit. The methyl bromide is usually injected by an applicator especially designed for this purpose, or it can be injected from the original cylinder by means of copper tubing. The cylinder is placed on a scale and the proper dosage is weighed out and forced through the copper tubing by the vapor pressure of the liquid. After fumigation the room should be thoroughly aired before entrance without a gas mask. The fruits, not yet wrapped, are packed loosely in the fumigation chamber. The room should have a false floor to provide for complete circulation. After treatment the product is wrapped and packed in an approved screened packing room and transferred, under canvas, to a refrigerated space on the boat. METHYL-BROMIDE ,VERSUS VAPOR-HEAT STERILIZATION Two factors must be considered in determining whether the methyl-bromide fumigation should replace the previously authorized vapor-heat treatment-cost of operation and probable loss ratio. 12 Circular 17, Hawaii Experiment Station While no exact figures are available, the vapor-heat treatment would appear to be the more costly. The expense of constructing a vapor-heat chamber would be greater, since better heat insulation and machinery for supplying the vapor heat are necessary. Cost of opera­tion would probably favor the methyl-bromide treatment, also, since the 2 pounds of gas required for 1,000 cubic feet cost only $1.70, and the time of operation is about one-half of that required for heat sterilization. Percentage of loss of the treated product is less readily established than expense. It depends on such factors as type of fruit, degree of maturity, and presence of decay organisms, and will be determined by varietal selection, clean cultivation, adequate spraying, and careful handling. Very little loss should occur when tomatoes are fumigated with methyl bromide, provided that the general recommendations are fol­lowed. Tomatoes also tolerate the vapor-heat treatment well, so that the aspect of cost would determine the preferred treatment. Papayas, on the other hand, have so far been subject to greater loss when treated with methyl bromide. Unless fruits free of anthrac­nose can be obtained, vapor-heat sterilization may be the more eco­nomical treatment. The experiment station will continue to study this point. SUMMARY PAPAYA 1. Fumigation with methyl bromide (2 pounds per 1,000 cubic feet for 3Yz hours) reduces the catalase activity of the papaya and causes a delay of 3 to 4 days in the ripening of firm-ripe fruits. 2. Papayas absorb and retain small quantities of methyl bromide. This residue imparts a slight taste to the fruits. 3. Anthracnose [ C olletotrichuni sp. (gloeosporioides ?) ] 1s the chief cause of loss of methyl-bromide-treated papayas. 13 Methyl-Bromide Fumigation TOMATO 1. Fumigation with methyl bromide delays ripening of the tomato from 3 to 6 days, depending on the maturity of the fruits. 2. The small amounts of bromide retained do not affect the quality of tomatoes. 3. Decay is not increased in tomatoes, in most cases, by the methyl-bromide treatment. It is of utmost importance, however, that only sound fruit be fumigated. RECOMMENDATIONS Based on the experimental work to date, the following recommen­dations may be made for the treatment of papayas and tomatoes with methyl bromide. These recommendations are subject to change as more experimental data accumulate. PAPAYA 1. Clean fruits are essential. Papayas to be treated with methyl bromide should be free from latent infections of Colletotrichum sp. (gloeosporioides ?) . It may be necessary to employ a spray program. 2. Papayas should be as ripe as can be handled without bruising­at least firm-ripe. Care in handling is always of the utmost impor­tance. A bruise or skin break on a fruit reduces its holding qualities and increases the percentage of loss. 3. Methyl-bromide-treated papayas should he placed in cold stor­age, at a temperature of 50° to 60° F., immediately after treatment. TOMATO 1. Tomatoes to be treated with methyl bromide should be free of all skin breaks and bruises. 2. "Pinks" should be placed in cold storage, at a temperature of 55° to 60° F. immediately after treatment with methyl bromide. Mature-green fruits should be held at room temperature until they become pink before they are placed in cold storage. Non:: All treatments are under the direction and supervision of the Bureau of Entomology and Plant Quarantine, U . S. Depart­ment of Agriculture. For details of treatment see this Bureau. 14 Circular 17, Hawaii Experiment Station LITERATURE CITED 1. BAKER, R. E. D. 1939. Notes on the diseases and fruit rots of tomatoes in the British TVest Indies. Trop. Agr. (Trinidad) 16 :252-257. 2. JONES, W. W. 1940. Vapor-heat treatment for fruits and vegetables grown in Hawaii. Hawaii Agr. Expt. Sta. Cir. 16, 8 pp. 3. -----, HOLZMAN, J. J., and GALLOWAY, A. G. 1939. The effect of high-temperature sterilization on the Solo papaya. Hawaii Agr. Expt. Sta. Cir. 14, 8 pp. 4. MACKIE, D. B. 1938. Methyl bromide-Its expectancy as a fumigant. Jour. Econ. Ent. 31 :70-79. 5. WARDLAW, C. W., BAKER, R. E. D., and CROWDY, S. H. 1939. Latent infections in tropical fruits. Trop. Agr. (Trinidad) 16 :275-276. 

Methyl-bromide fumigation of papaya and tomato

http://scholarspace.manoa.hawaii.edu/bitstream/10125/53692/1/CtahrpsCirc2-17.pdf

Methyl-bromide fumigation of papaya and tomato

Abstract

Similar works

Full text

Available Versions

ScholarSpace at University of Hawai'i at Manoa