BackgroundThe dose of protamine required following cardiopulmonary bypass (CPB) is often determined by the dose of heparin required pre-CPB, expressed as a fixed ratio. Dosing based on mathematical models of heparin clearance is postulated to improve protamine dosing precision and coagulation. We hypothesised that protamine dosing based on a 2-compartment model would improve thromboelastography (TEG) parameters and reduce the dose of protamine administered, relative to a fixed ratio.Methods and findingsWe undertook a 2-stage, adaptive randomised controlled trial, allocating 228 participants to receive protamine dosed according to a mathematical model of heparin clearance or a fixed ratio of 1 mg of protamine for every 100 IU of heparin required to establish anticoagulation pre-CPB. A planned, blinded interim analysis was undertaken after the recruitment of 50% of the study cohort. Following this, the randomisation ratio was adapted from 1:1 to 1:1.33 to increase recruitment to the superior arm while maintaining study power. At the conclusion of trial recruitment, we had randomised 121 patients to the intervention arm and 107 patients to the control arm. The primary endpoint was kaolin TEG r-time measured 3 minutes after protamine administration at the end of CPB. Secondary endpoints included ratio of kaolin TEG r-time pre-CPB to the same metric following protamine administration, requirement for allogeneic red cell transfusion, intercostal catheter drainage at 4 hours postoperatively, and the requirement for reoperation due to bleeding. The trial was listed on a clinical trial registry (ClinicalTrials.gov Identifier: NCT03532594). Participants were recruited between April 2018 and August 2019. Those in the intervention/model group had a shorter mean kaolin r-time (6.58 [SD 2.50] vs. 8.08 [SD 3.98] minutes; p = 0.0016) post-CPB. The post-protamine thromboelastogram of the model group was closer to pre-CPB parameters (median pre-CPB to post-protamine kaolin r-time ratio 0.96 [IQR 0.78-1.14] vs. 0.75 [IQR 0.57-0.99]; p 120 kg, and patients requiring therapeutic hypothermia to ConclusionsUsing a mathematical model to guide protamine dosing in patients following CPB improved TEG r-time and reduced the dose administered relative to a fixed ratio. No differences were detected in postoperative mediastinal/pleural drainage or red blood cell transfusion requirement in our cohort of low-risk patients.Trial registrationClinicalTrials.gov Unique identifier NCT03532594