Abstract A 65-year-old male originally had surgery for spondylolisthesis at L5-S1 in 2008 and then went on to have an L4-5 transforaminal lumbar interbody fusion (TLIF) with pedicle screw fixation from L4 to S1 and interbody graft in 2010. Despite having two surgical procedures, he continued with intractable back pain and was told he had a failed lumbar fusion. When he was evaluated with a computerized tomography (CT) scan from April 2015, it demonstrated an erosive nonunion of the L4-5 interbody fusion without incorporation of the polyetheretherketone (PEEK) cage. In an attempt to perform a minimally invasive stabilization of the L4-5 nonunion, he underwent a percutaneous lateral foraminal approach with an injection of Cortoss® cement (Stryker®, Malvern, PA) into the L4-5 interspace and around the graft. The objective was to stabilize the nonunion, resulting in intermediate relief of pain

Michelle Granville

Robert E Jacobson

CiteSeerX

Received 12/01/2016 
Review began  12/29/2016 
Review ended  01/14/2017 
Published 01/20/2017
© Copyright 2017
Granville et al. This is an open
access article distributed under the
terms of the Creative Commons
Attribution License CC-BY 3.0.,
which permits unrestricted use,
distribution, and reproduction in any
medium, provided the original
author and source are credited.
An Innovative Use of Cortoss Bone Cement
to Stabilize a Nonunion after Interbody
Fusion
Michelle Granville  , Robert E. Jacobson 
1. Miami Neurosurgical Center, University of Miami Hospital
 Corresponding author: Michelle Granville, mgranville@hotmail.com 
Disclosures can be found in Additional Information at the end of the article
Abstract
A 65-year-old male originally had surgery for spondylolisthesis at L5-S1 in 2008 and then went
on to have an L4-5 transforaminal lumbar interbody fusion (TLIF) with pedicle screw fixation
from L4 to S1 and interbody graft in 2010. Despite having two surgical procedures, he
continued with intractable back pain and was told he had a failed lumbar fusion. When he was
evaluated with a computerized tomography (CT) scan from April 2015, it demonstrated an
erosive nonunion of the L4-5 interbody fusion without incorporation of the
polyetheretherketone (PEEK) cage. In an attempt to perform a minimally invasive stabilization
of the L4-5 nonunion, he underwent a percutaneous lateral foraminal approach with an
injection of Cortoss® cement (Stryker®, Malvern, PA) into the L4-5 interspace and around the
graft. The objective was to stabilize the nonunion, resulting in intermediate relief of pain.
Categories: Pain Management, Neurosurgery
Keywords: failed fusion, failed back syndrome, minimally invasive
Introduction
A 65-year-old male was evaluated six months after refusing surgery at another clinic for
increased severe and persistent deep low lumbar pain after multiple previous lumbar surgeries.
The pain actually worsened after an L4-5 interbody graft and pedicle screw fixation from L4 to
S1. He was evaluated with plain X-rays and CT scan, including a fine-cut CT, which
demonstrated nonunion and actual endplate subsidence and erosion both inferiorly at L4 and
superiorly at L5, as shown in Figures 1-2. In order to ensure the patient did not have
osteomyelitis or an underlying infection, a sedimentation rate, white blood cell (WBC) count,
and bone scan were ordered and found to be within normal limits.
1 1
 
Open Access Technical
Report  DOI: 10.7759/cureus.986
How to cite this article
Granville M, Jacobson R E (January 20, 2017) An Innovative Use of Cortoss Bone Cement to Stabilize a
Nonunion after Interbody Fusion. Cureus 9(1): e986. DOI 10.7759/cureus.986
FIGURE 1: Lateral X-ray appears to show the graft in place;
however, L4-5 is not fused.
2017 Granville et al. Cureus 9(1): e986. DOI 10.7759/cureus.986 2 of 8
FIGURE 2: Sagittal CT reconstruction shows erosion of the
endplates and rotation of the graft.
After careful review of all the findings, it was felt that a repeat laminectomy with an attempt to
remove or replace the interbody graft posteriorly would be difficult, so the patient was offered
an extreme lateral lumbar interbody fusion (XLIF) to approach the L4-5 space laterally, allowing
both debridement and grafting. However, the patient refused this procedure. It was
subsequently suggested that it might be possible to enter the disc space endoscopically, curette
the area, and then place Cortoss®, a bioactive bone cement (Stryker®, Malvern, PA), around the
graft to support the disc space. He was explained that if we could not debride and remove
fibrous scar around the graft, it would be less likely the cement would be helpful. He agreed to
2017 Granville et al. Cureus 9(1): e986. DOI 10.7759/cureus.986 3 of 8
undergo minimally invasive stabilization with Cortoss, understanding that he may have to
endure another surgical procedure in the future. Informed patient consent was obtained for
treatment.
Technical Report
The patient was taken to the procedure room and placed in a left lateral decubitus position
with a roll underneath his left flank and his knees bent. He was then given monitored
anesthesia care (MAC) sedation, the skin was prepped and draped, and the L4-5 region was
identified with fluoroscopy. Local anesthesia with 1% lidocaine and 0.5% Marcaine was then
administered to the area. Using a 20 gauge needle, anesthesia was also placed down to the
foraminal margin of the disc, just under the mid-pedicle line. A guide wire was passed, and a 4
mm Stryker vertebroplasty cannula was passed along the guide wire and impacted into the
posterolateral margin of the L4-5 disc space. The position was confirmed on AP and lateral
fluoroscopy. A trocar was then impacted into the disc space. The annulus and outer capsule of
the disc were incised with a manual spiral drill, and as the drill was passed into the disc space
under fluoroscopy, the graft could be felt. The adjustable vertebroplasty curette and 3.1 mm
pituitary and scope curettes were passed around the graft, as well as above and below the
endplate of L4 and L5. The space was irrigated with normal saline, and as the endplate was
curetted, some mild bleeding occurred indicating the bone was being debrided, as shown in
Figure 3. Four pipettes were then filled with 0.7 cc of Cortoss (totaling 2.8 cc of Cortoss), which
were subsequently injected into the L4-5 disc space surrounding the graft and spreading both
inferiorly towards the superior margin of L5 and superiorly into the inferior margin of L4. There
was minor spread along the posterior longitudinal ligament as well, but no extravasation of dye
was identified, as shown in Figure 4. Then the trocar was pulled out, minor bleeding was
contained, and Dermabond® (Ethicon, Somerville, NJ) and Steri-Strips™ (3M, St. Paul, MN)
were placed over the incision.
2017 Granville et al. Cureus 9(1): e986. DOI 10.7759/cureus.986 4 of 8
FIGURE 3: Intraoperative photograph of bone drill, curette, and
pituitary ronguer debriding the L4-5 interspace.
2017 Granville et al. Cureus 9(1): e986. DOI 10.7759/cureus.986 5 of 8
FIGURE 4: Post-procedure shows cement fill at L4-5.
The entire operative time was 33 minutes. The patient tolerated the procedure well and was
sent home the same day. He was seen at the office for follow-up three days later complaining of
mild soreness in his lumbar region near the incision. A six-month follow-up showed the patient
had a 50% reduction in his pain.
Discussion
Failure to fuse after lumbar surgery has numerous causes. Statistics show that advanced age and
habitual smoking increase the risk and delay the healing process [1-2]. The ultimate goal of
spinal fusion surgery involves setting up a natural response that causes bone to grow between
two vertebras, hence, stopping motion at a given segment of the spine. This can be achieved by
adding a bone graft or inserting a cage made of synthetic material, such as
polyetheretherketone (PEEK) cages or titanium into the disc space [3]. It is documented that
with proper preparation of the interspace and fusion bed, PEEK cages fuse at a high percentage
rate when compared to titanium cages [3-4]. Posterior pedicle screw fixation over three levels
should provide stability on both the posterior and middle column. However, if no adjacent facet
or interlaminar fusion is performed, then failure of the anterior column PEEK cage could lead to
instability since the disc space is extensively debrided of both the nucleus and some annulus in
creating the bed for the PEEK cage [3]. It is well documented that settling of PEEK cages into
the adjacent endplates is a significant problem and the possible cause of postoperative pain due
to bone erosion as seen in this case [3-4].  
This is the first reported case of using Cortoss, especially percutaneously, through a minimally
2017 Granville et al. Cureus 9(1): e986. DOI 10.7759/cureus.986 6 of 8
invasive tubular approach under local anesthesia as a means to stabilize a failed interbody bone
graft. There are reports of using polymethylmethacrylate (PMMA), which has a higher viscosity
when compared to Cortoss, for stabilizing vertebral body metastatic tumors and as an adjunct
during open surgery to fill voids for vertebral body replacement [5-6]. Cortoss is the first
clinically sustained substitute to PMMA, which has both calcium and phosphate polymers
mixed with micro glass that binds to bone, giving it similar properties to human bone [6-7].
This also allows it to reach around 75% of the biomechanical strength of cortical bone within 15
minutes of injection [8-9]. Thus, this allowed for significant support so there was a reasonable
chance of not only stabilizing the graft but actually enhancing the ability of the graft to fuse
and incorporate the interbody PEEK cage and lead with the L4 and L5 endplates. 
Conclusions
In the last several years, various methods have been developed to place PEEK cages and grafts
in the disc space with the goal of increasing bony growth to allow adequate fusion. This case
demonstrates that it is possible to stabilize a nonunion of a lumbar interbody graft using a
variation of the technique for transforaminal lumbar endoscopic discectomy and combining
this approach with the use of bone cement. This made it possible to offer the patient a
minimally invasive short and median term solution to a complex interbody fusion nonunion
failure.
Additional Information
Disclosures
Animal subjects: This study did not involve animal subjects or tissue. Human subjects:
Consent was obtained by all participants in this study.
Acknowledgements
I would like to acknowledge Maria Freed, administrator of Coral Gables Surgery Center.
References
1. Rohde V, Mielke D, Ryang Y, Gilsbach JM: The immediately failed lumbar disc surgery:
incidence, aetiologies, imaging and management. Neurosurg Rev. 2015, 38:191-95.
10.1007/s10143-014-0573-3
2. Kerr EJ 3rd, Jawahar A, Wooten T, Kay S, Cavanaugh DA, Nunley PD: The use of osteo-
conductive stem-cells allograft in lumbar interbody fusion procedures: an alternative to
recombinant human bone morphogenetic protein. J Surg Orthop Adv. 2011, 20:193-97.
3. Chong E, Pelletier MH, Mobbs RJ, Walsh WR: The design evolution of interbody cages in
anterior cervical discectomy and fusion: a systematic review. BMC Musculoskelet Disord.
2015, 16:99. 10.1186/s12891-015-0546-x
4. Williams AL, Gornet MF, Burkus JK: CT evaluation of lumbar interbody fusion: current
concepts. AJNR Am J Neuroradiol. 2005, 26:2057-66.
5. Hayeri MR, Tehranzadeh J: Diagnostic imaging of spinal fusion and complications . Appl
Radiol. 2009, Accessed: 11/02/2016: http://appliedradiology.com/articles/diagnostic-imaging-
of-spinal-fusion-and-complications.
6. Erbe EM, Clineff TK, Gualtieri G: Comparison of a new bisphenol-a-glycidyl dimethacrylate-
based cortical bone void filler with polymethyl methacrylate. Eur Spine J. 2001, 10:S147-52.
10.1007/s005860100288
7. Bae H, Hatten HP Jr, Linovitz R, Tahernia AD, Schaufele MK, McCollom V, Gilula L, Maurer P,
Benyamin R, Mathis JM, Persenaire M: A prospective randomized FDA-IDE trial comparing
Cortoss with PMMA for vertebroplasty: a comparative effectiveness research study with 24-
month follow-up. Spine (Phila Pa 1976). 2012, 37:544-50. 10.1097/BRS.0b013e31822ba50b
8. Cook WD, Standish PM: Polymerization kinetics of resin-based restorative materials . J Biomed
2017 Granville et al. Cureus 9(1): e986. DOI 10.7759/cureus.986 7 of 8
Mater Res. 1983, 17:275–82. 10.1002/jbm.820170206
9. Fan S, Hu Z, Zhao F, Zhao X, Huang Y, Fang X: Multifidus muscle changes and clinical effects
of one-level posterior lumbar interbody fusion: minimally invasive procedure versus
conventional open approach. Eur Spine J. 2010, 19:316–24. 10.1007/s00586-009-1191-6
2017 Granville et al. Cureus 9(1): e986. DOI 10.7759/cureus.986 8 of 8


An Innovative Use of Cortoss Bone Cement to Stabilize a Nonunion after Interbody Fusion

http://citeseerx.ist.psu.edu/viewdoc/download;jsessionid=A337E668169A472B09C8790CE4708EDD?doi=10.1.1.1046.3559&rep=rep1&type=pdf

An Innovative Use of Cortoss Bone Cement to Stabilize a Nonunion after Interbody Fusion

Abstract

Similar works

Full text

Available Versions

CiteSeerX