THE INFLUENCE OF IONIZING RADIATION ON THE THERMOPHYSICAL PROPERTIES OF MEAT FROM THE BROILER CHICKENS WITH DIFFERENT STRESS RESISTANCE

The studies on the influence of radiation treatment of carcasses from the stress-resistant and stress-sensitive broiler chickens on the thermophysical properties of raw meat are presented. An increase in thermal diffusivity of meat from the stress-resistant poultry by 24.7 % and 54.7 % after radiation treatment of carcasses with ionizing radiation doses of 9 kGy and 12 kGy, respectively, was established. In meat from the stress-sensitive poultry, this figure increased by 33.3 % and 35.8 % compared to the untreated carcasses.It is shown that radiation treatment of carcasses by applied doses increased the thermal conductivity coefficient of meat from the stressresistant poultry by 5.3% and 7.0 %; in meat from the stress-sensitive poultry, this figure increased by 2.0 and 6.2 times compared to meat from the carcasses not exposed to radiation. At the same time, the value of the heat capacity coefficient was reduced. The irradiated poultry meat samples accumulate energy of ionizing radiation more intensively, which allows the intensification of the thermal processes occurring at various stages of meat product production. Treatment of meat from the stress-resistant poultry with ionizing radiation can reduce the amount of meat with non-traditional autolysis due to changes in its functionaltechnological properties. The results of the research should be taken into account in technological processes in the production of meat products with non-traditional autolysis.The studies on the influence of radiation treatment of carcasses from the stress-resistant and stress-sensitive broiler chickens on the thermophysical properties of raw meat are presented. An increase in thermal diffusivity of meat from the stress-resistant poultry by 24.7 % and 54.7 % after radiation treatment of carcasses with ionizing radiation doses of 9 kGy and 12 kGy, respectively, was established. In meat from the stress-sensitive poultry, this figure increased by 33.3 % and 35.8 % compared to the untreated carcasses.It is shown that radiation treatment of carcasses by applied doses increased the thermal conductivity coefficient of meat from the stressresistant poultry by 5.3% and 7.0 %; in meat from the stress-sensitive poultry, this figure increased by 2.0 and 6.2 times compared to meat from the carcasses not exposed to radiation. At the same time, the value of the heat capacity coefficient was reduced. The irradiated poultry meat samples accumulate energy of ionizing radiation more intensively, which allows the intensification of the thermal processes occurring at various stages of meat product production. Treatment of meat from the stress-resistant poultry with ionizing radiation can reduce the amount of meat with non-traditional autolysis due to changes in its functionaltechnological properties. The results of the research should be taken into account in technological processes in the production of meat products with non-traditional autolysis

THE INFLUENCE OF IONIZING RADIATION ON THE THERMOPHYSICAL PROPERTIES OF MEAT FROM THE BROILER CHICKENS WITH DIFFERENT STRESS RESISTANCE

The studies on the influence of radiation treatment of carcasses from the stress-resistant and stress-sensitive broiler chickens on the thermophysical properties of raw meat are presented. An increase in thermal diffusivity of meat from the stress-resistant poultry by 24.7 % and 54.7 % after radiation treatment of carcasses with ionizing radiation doses of 9 kGy and 12 kGy, respectively, was established. In meat from the stress-sensitive poultry, this figure increased by 33.3 % and 35.8 % compared to the untreated carcasses.It is shown that radiation treatment of carcasses by applied doses increased the thermal conductivity coefficient of meat from the stressresistant poultry by 5.3% and 7.0 %; in meat from the stress-sensitive poultry, this figure increased by 2.0 and 6.2 times compared to meat from the carcasses not exposed to radiation. At the same time, the value of the heat capacity coefficient was reduced. The irradiated poultry meat samples accumulate energy of ionizing radiation more intensively, which allows the intensification of the thermal processes occurring at various stages of meat product production. Treatment of meat from the stress-resistant poultry with ionizing radiation can reduce the amount of meat with non-traditional autolysis due to changes in its functionaltechnological properties. The results of the research should be taken into account in technological processes in the production of meat products with non-traditional autolysis

ВЛИЯНИЕ КОЛБАСЫ ВАРЕНОЙ ОБОГАЩЕННОЙ ЛАКТУЛОЗОЙ И ПИЩЕВЫМИ ВОЛОКНАМИ НА МОРФОФУНКЦИОНАЛЬНОЕ СОСТОЯНИЕ СЛИЗИСТОЙ ОБОЛОЧКИ ТОЛСТОГО КИШЕЧНИКА И МИКРОБИОЦЕНОЗ У КРЫС

The researches on the development of medical and medical-preventive food products for people with violation of normal intestinal microflora are presented in the article. It was found that,  the introduction into the formulation of cooked sausage food beet  fibers based on sugar beet, hydrated in a ratio 1:5, in amount 10 %  to weight of mince and lactulose, synthesized from lactose, in  amount 640 mg/kg mince retains the traditional organoleptic  properties of the product. There were carried out comparative  morphometric, histochemical and bacterioscopic studies of boiled  sausage effect without additives and sausage enriched with food  fibers and lactulose on the morphofunctional condition of the mucous membrance of the colon (MMC) of rats. Was shown a significant  height  increase of epithelial surface of epithelium, an increase of frequency mitoses in the epithelium crypts of intestinal glands (from 0.6 ± 0.08 % to 1.1 ± 0.04 %), there is a tendency of increasing  content of goblet ekzokrinnye (from 21.3 ± 5.5 % to 32.4 ± 18.7  %), while the mucosal were intensively produced allopathically  mucus, which indicates the stimulation of sausage, enriched with  lactulose on the functional status of the surface epithelium and intestinal glands of the mucous membrane of the colon. Based on the studies results of the effect of food beet fibers and lactulose,  contained in the ration of rats in large and small intestine were fixed  on order greater amount of bifido- and lactobacteries in comparison  with the animals control group. Same time, it was found that in the  large intestine the number of lactobacilli were much higher in  animals receiving experimental sausage.В статье представлены исследования по разработке продуктов лечебного и лечебно-профилактического питания для людей с нарушением нормальной кишечной микрофлоры.  Установлено, что введение в рецептуру вареной колбасы пищевых свекловичных волокон  на основе сахарной свеклы, гидратированных в соотношении 1:5, в количестве 10 % к массе фарша и лактулозного сиропа, синтезированного из молочного сахара, в количестве  640 мг/кг фарша сохраняет традиционные органолептические свойства продукта.  Проведены сравнительные морфометрические, гистохимические и бактериоскопические  исследования влияния вареной колбасы без добавок и колбасы обогащенной пищевыми волокнами и лактулозой на морфофункциональное состояние слизистой оболочки толстого кишечника (СОТК) крыс. Показано значимое увеличение высоты эпителиоцитов  поверхностного эпителия, возрастание частоты митозов в эпителии крипт кишечных желез  (с 0,6 ± 0,08 % до 1,1 ± 0,04 %), имеется тенденция к повышению содержания бокаловидных экзокриноцитов (с 21,3 ± 5,5 % до 32,4 ± 18,7 %), при этом мукоциты  интенсивно продуцировали альцианпозитивную слизь, что свидетельствует о  стимулирующем влиянии колбасы, обогащенной лактулозой, на функциональное состояние  поверхностного эпителия и кишечных желез слизистой оболочки толстой кишки. На  основании результатов исследований влияния пищевых свекловичных волокон и лактулозы, содержащихся в рационе крыс в толстом и тонком кишечнике зафиксировано на порядок большее количество бифидо- и лактобактерий в сравнении с контрольной группой  животных. Одновременно установлено, что в толстом кишечнике у животных получавших экспериментальную колбасу на порядок выше количество лактобактерий

THE IMPACT OF THE COOKED SAUSAGE ENRICHED WITH LACTULOSE AND FOOD FIBERS ON THE MORPHOFUNCTIONAL CONDITION OF THE MUCOUS MEMBRANE OF THE LARGE INTESTINE AND MICROBIOTA (MICROBIOCENOSIS) IN RATS

The researches on the development of medical and medical-preventive food products for people with violation of normal intestinal microflora are presented in the article. It was found that,  the introduction into the formulation of cooked sausage food beet  fibers based on sugar beet, hydrated in a ratio 1:5, in amount 10 %  to weight of mince and lactulose, synthesized from lactose, in  amount 640 mg/kg mince retains the traditional organoleptic  properties of the product. There were carried out comparative  morphometric, histochemical and bacterioscopic studies of boiled  sausage effect without additives and sausage enriched with food  fibers and lactulose on the morphofunctional condition of the mucous membrance of the colon (MMC) of rats. Was shown a significant  height  increase of epithelial surface of epithelium, an increase of frequency mitoses in the epithelium crypts of intestinal glands (from 0.6 ± 0.08 % to 1.1 ± 0.04 %), there is a tendency of increasing  content of goblet ekzokrinnye (from 21.3 ± 5.5 % to 32.4 ± 18.7  %), while the mucosal were intensively produced allopathically  mucus, which indicates the stimulation of sausage, enriched with  lactulose on the functional status of the surface epithelium and intestinal glands of the mucous membrane of the colon. Based on the studies results of the effect of food beet fibers and lactulose,  contained in the ration of rats in large and small intestine were fixed  on order greater amount of bifido- and lactobacteries in comparison  with the animals control group. Same time, it was found that in the  large intestine the number of lactobacilli were much higher in  animals receiving experimental sausage

Efficiency of Microencapsulation of Proteolytic Enzymes

Currently, special attention is paid to the study of the effectiveness of the immobilization method—microencapsulation. The aim of the research is to obtain a complex enzyme preparation from pepsin and papain by sequential microencapsulation of enzymes in a pseudo-boiling layer and to evaluate its tenderizing effect on pork. The objects of research were enzymes: pepsin and papain, which were microencapsulated in a protective coating of maltodextrin. It was found that the biocatalytic activity of the complex enzyme preparation is higher than that of pure enzymes. Microencapsulation allows maintaining the high proteolytic activity of enzymes for a long storage period. It has been shown that the thickness of the protective layer during microencapsulation of pepsin and papain in the pseudo-boiling layer of maltodextrin should be in the range of 4–6 microns. During the research, the physicochemical properties of pork were studied depending on the duration of fermentation. It was found that the maximum activity of immobilized enzymes is shifted to the alkaline side. Pork salting with the use of a microencapsulated enzyme preparation in the brine increases the water-binding capacity of proteins to a greater extent in comparison with brine with pure enzymes. The presented data show the high efficiency of sequential microencapsulation of the enzyme pepsin and then papain into a protective layer of maltodextrin in order to preserve their activity during storage

Biotechnology for bacteriocin synthesis using photostimulation

This article presents results of a study of the effect of blue color on the bacteriocin activity. It was revealed that photostimulation of Lactobacillus Lactis with light in the blue spectrum (435-470 nm) with a light flux intensity of 1800 mcd for 50-60 minutes positively affects the bacteriocin activity (increases by 60.1%), while titer of the Lactobacillus lactis is 2 times higher. It was found that it was in the first 18 hours that the irradiated samples had a greater difference in terms of activity and titers than unirradiated samples. Oxidative stress affects the culture’s viability, both in samples treated with blue light and in the untreated cultures. However, impact intensity on the treated cultures is weaker. These outcomes indicate the possibility of using blue light for stimulating bacteriocin biosynthesis in order to use it as a food additive for prolongation of shelf life of food products