Current status of MHI’s CO2 recovery technology and optimization of CO2 recovery plant with a PC fired power plant

AbstractIt is the opinion of the authors that CO2 Capture and Storage (CCS) technology can significantly contribute as an effective countermeasure against climate change, allowing us to continue the utilization of fossil fuels for primary energy production. However for this technology to be widely deployed on a commercial basis there are three key issues that need to be addressed; (1) Reduction in energy consumption, (2) Efficient integration with other environmental control equipment of a PC power plant and (3) Reduction in the decrease of net electrical output.MHI has delivered multiple commercial CO2 recovery plants in the chemical and fertilizer industries, which recover CO2 from natural gas fired flue gas, with four commercial plants in operation and another four under construction, all utilizing the proprietary KM-CDR process.In order to gain experience with CO2 recovery from a coal fired flue gas stream, Mitsubishi Heavy Industries (MHI), together with a subsidy from RITE and cooperation from J-POWER, constructed a 10 metric ton per day (T/D) CO2 recovery demonstration plant at the 2×500 MW Matsushima power station in southern Japan. This demonstration plant has subsequently achieved more than 4,000 hours of successful test operation during 2006–2007 with a further 1,000 hours during 2008, and testing continues today. The demonstration testing confirmed that the KM-CDR process is applicable to coal fired flue gas streams. Future research priorities include the improved integration of the CO2 recovery process with the flue gas pre-treatment components and the additional optimization of removal and separation methods for coal based impurities accumulating in the absorbent.An issue of concern for power plant operators is the reduction of the net electrical output due to the demands of CO2 recovery process. MHI has made significant improvements in this area and in the efficiency of absorbents. However, it is necessary to further reduce the adverse impact on the net electrical output of the power plant via astute integration of the energy transferred between the power plant and the Post Combustion CO2 Capture (PCC) plant. MHI is investigating the following concepts; (1) Utilizing the waste heat of the PCC plant for the power plant, (2) Utilizing heat recovery from the flue gas for the CO2 recovery process and (3) Utilizing the compression heat of the CO2 compressor for the CO2 recovery process

Distribution and Endocrine Morphology of Polypeptide YY (PYY) Containing Cells in the Human Gut

Using human materials, the distribution of PYY containing cells was determined by immunocytochemical methods and discussion was made on their morphological endocrinology. PYY cells were fairly numerous in the lower gastrointestinal tract of man, particularly in the colon and rectum. The cells were also present in the pancreas and duodenum but quite rarely. PYY cells were not observed at all in the lower part of the esophagus, stomach and gall bladder. Their peculiar and characteristic shapes as well as distribution suggest that PYY may have some action (probably specific) on the function of the distal gastrointestinal tract

Preventive Effect of Proglumide on Erosive Gastritis in the Rat

The purpose of this study is to determine whether or not proglumide has a preventive effect on the erosive gastritis induced by sodium salt of taurocholic acid (TCA) in the rat. Its effect on the formation of gastric erosions, serum gastrin levels and secretion of acid and pepsin were also studied. The rats were given standard feed containing 0.25% proglumide and water containing 5mM TCA (experimental E group). The control rats were given standard feed and water containing 5mM TCA (TCA group). All rats were killed at the end of the 3 months. The tissue specimens of the resected gastric mucosa were stained with hematoxylin eosin for histopathology and with azan for evaluation of fibrous ploriferation. From microscopic observation of the stained specimens, the following results were obtained. TCA-group showed long mucosal surface injury (erosion), inflammatory cell infiltration, a reduction in the number of parietal cells, a decrease of mucosal thickness, and proliferation of collagenous fiber. In contrast, in the E group, these morphological and morphoquantitative changes were significantly small. The length of erosion and inflammatory cell infiltration were significantly reduced in the E group when compared with the TCA group. Furthermore, mucosal thickness was almost normal and fibrous proliferation was significantly scarce in the E group. Proglumide had an insignificant effect on pH on the mucosa, volume and pH of gastric juice, serum gastrin levels and tetragastrin-induced secretion of acid and pepsin. It is, thus, evident that proglumide has a preventive effect on the induction of erosive gastritis caused by TCA in the rats. Since it is difficult to explain its mechanism for the prevention of gastritis from only the already known facts that it has protective action on gastric mucosa and an inhibitory effect on secretion of acid and pepsin, unknown mechanisms are suspected to be involved

A Case of an Invasive Lobular Carcinoma with Extracellular Mucin: Radio-Pathological Correlation

A case of 77-year-old female with an invasive lobular carcinoma with extracellular mucin is presented. She felt palpable mass in her left breast. Then, she came to our hospital for further examination. Mammography of right in full view revealed architectural distortion in left upper portion. And ultrasonography demonstrated low-echoic mass about 2 cm in diameter and invasion of the fat tissue was observed. Hence, malignancy was suspected and magnetic resonance imaging (MRI) was performed. MRI findings showed irregular shaped and margined mass with small T2-high-signal intensity. These findings suggested invasive carcinoma with mucin. Because the cancer lesion was not large, partial mastectomy was performed. Interestingly, pathological diagnosis was invasive lobular carcinoma with extracellular mucin. Extracellular mucinous lesion was concordant with small T2-high-signal intensity. This type of carcinoma was previously reported only in three cases, and rare but important, because the treatment and prognosis might change by histological subtypes. We suggest one of the MRI special features of our case is not only irregular shaped and margined mass but also small T2-high-signal intensity. These MR findings might be one of the valuable findings for the diagnosis and differentiation between this type of carcinoma from other tumors

Endocrine Profile in Rats with Postgastrectomy Malabsorption: a Pilot Study

Abnormal endocrine profile, especially in the enteropancreatic axis, was described in rats with malnutrition caused by malabsorption after total gastrectomy. Insulin, substance P and motilin concentrations at the fasting condition were significantly elevated in malnutritious rats after total gastrectomy when compared to those in control rats. A significant elevation of pancreatic glucagon and motilin was noted after intraduodenal fat administration in malnutritious rats. These data suggest that these peptides of many humoral factors may thus cause abnormal enteropancreatic axis and consequent malnutrition

A Galanin-Like Peptide in the Colon of the Golden Hamster

Galanin-like immunoreactive peptide was studied in the colonic wall of the golden hamster using the immunoflurescent technique. Galanin-like immunoreactivity was observed mainly in cell bodies of the myenteric plexus and in fibers in the lamina propria mucosae and in the circular muscle layer. The submucosal plexus and submucosal connective tissue, however, contained very little galanin-like immunoreactive peptide. This peptide appears to be instrinsic mainly to the colon. The presence of the peptide indicates some possible biological roles in the colonic function

Induction of Experimental Atrophic Gastritis by N-Methyl-N'-Nitro-N-Nitrosoguanidine or Taurocholic Acid in Donryu Rats

The morphology of the rat (Donryu) gastric mucosa was examined by light microscopy after administration of N-methyl-N'-nitro-N-nitrosoguanidine (MNNG) or taurocholic acid (TCA), a component of bile acids. MNNG was given to rats ad libitum from light-sealed bottles for 5 months and deionized water was given freely for 6 months thereafter. TCA was administered to rats freely for 11 months. Deionized water was given to rats as control (non-treated rats). Rats treated with MNNG or TCA and control rats were killed at 11 months after the beginning of the experiment. Using 3 micron tissue samples taken from the area of the gastric mucosa designated before the experiment, hematoxylin and eosin and azan stain were made for histopathological evaluation and fibrosis. Marked atrophic changes, such as reduction in the number of parietal cells, shortened mucosa! length, inflammaotry cell infiltration, and proliferation of fibrosis, were present in the gastric mucosa of rats treated with MNNG as well as TCA. These findings were typical for atrophic gastritis. Such atrophic changes were slight in the gastric mucosa of the control rats. The frequency of tumourous lesions was very low in MNNG-treated rats. We have concluded on the basis of the present data that MNNG as well as TCA can induce atrophic gastritis in Donryu rats

New readout and data-acquisition system in an electron-tracking Compton camera for MeV gamma-ray astronomy (SMILE-II)

For MeV gamma-ray astronomy, we have developed an electron-tracking Compton camera (ETCC) as a MeV gamma-ray telescope capable of rejecting the radiation background and attaining the high sensitivity of near 1 mCrab in space. Our ETCC comprises a gaseous time-projection chamber (TPC) with a micro pattern gas detector for tracking recoil electrons and a position-sensitive scintillation camera for detecting scattered gamma rays. After the success of a first balloon experiment in 2006 with a small ETCC (using a 10$\times$10$\times$15 cm$^3$ TPC) for measuring diffuse cosmic and atmospheric sub-MeV gamma rays (Sub-MeV gamma-ray Imaging Loaded-on-balloon Experiment I; SMILE-I), a (30 cm)$^{3}$ medium-sized ETCC was developed to measure MeV gamma-ray spectra from celestial sources, such as the Crab Nebula, with single-day balloon flights (SMILE-II). To achieve this goal, a 100-times-larger detection area compared with that of SMILE-I is required without changing the weight or power consumption of the detector system. In addition, the event rate is also expected to dramatically increase during observation. Here, we describe both the concept and the performance of the new data-acquisition system with this (30 cm)$^{3}$ ETCC to manage 100 times more data while satisfying the severe restrictions regarding the weight and power consumption imposed by a balloon-borne observation. In particular, to improve the detection efficiency of the fine tracks in the TPC from $\sim$10\% to $\sim$100\%, we introduce a new data-handling algorithm in the TPC. Therefore, for efficient management of such large amounts of data, we developed a data-acquisition system with parallel data flow.Comment: 11 pages, 24 figure