Efecto de pretratamientos con microondas a semillas de colza sobre la cinética de degradación de los compuestos bioactivos lipófilos del aceite durante el almacenamiento

This study examined the storage stability of tocochromanols and carotenoids in the oils prepared from microwave pre-treated (MV) rapeseeds (2-10 min, 800W) during storage at 20 °C for 12 months. In line with lipophilic antioxidant degradation throughout the storage period, changes in the antioxidant capacity of the oil were monitored. Microwaving significantly affected the concentration of lipophilic antioxidants in the oil. After 10 min of MV pre-treatment the highest content of total tocochromanols (76.64 mg/100g) was achieved, whereas a maximum carotenoid concentration (861.28 μg/100g) was obtained following 6 min seed MV pre-treatment. The degradation kinetics for the tocochromanols and carotenoids followed a zero-order kinetic model. From the kinetic analysis, it was shown that the degradation rate constant (k) of both tocochromanols and carotenoids decreased with longer seed exposure to MV radiation. The kinetics of antioxidant capacity degradation during the storage of oils followed a zero-order reaction. The rate of antioxidant capacity degradation in the control oil was higher (k=9.1 x 10-2 mmol TEAC/l/month) compared with oils prepared from MV pre-treated seeds (k=6.8-8.0 x 10-2 mmol TEAC/l/month).En este estudio se determinó la estabilidad de tococromanoles y carotenoides de aceites preparados a partir de semillas de colza pretratadas con microondas (MV) (2-10 min, 800 W) durante el almacenamiento a 20 °C durante 12 meses. De acuerdo con la degradación de los antioxidantes lipófilos durante el periodo de almacenamiento, se monitorizó el cambio en la capacidad antioxidante del aceite. El microondas afectó significativamente a la concentración de antioxidantes lipofilícos en el aceite. Después de 10 minutos de pretratamiento con MV, se obtuvo el contenido más alto de tocromanoles totales (76,64 mg/100 g), mientras que se obtuvo una concentración máxima de carotenoides (861,28 g/100 g) después de un pretratamiento con MV de 6 minutos. La cinética de degradación para los tococromanoles y carotenoides siguió un modelo cinético de orden cero. A partir del análisis cinético, se demostró que la constante de velocidad de degradación (k) tanto de los tococromanoles como de los carotenoides disminuía con una exposición más prolongada de las semillas a la radiación de MV. La cinética de la degradación de la capacidad antioxidante durante el almacenamiento de los aceites siguió una reacción de orden cero. La tasa de degradación de la capacidad antioxidante en el aceite testigo fue mayor (k = 9,1 x 10-2 mmol TEAC / l / mes) en comparación con los aceites preparados a partir de semillas pretratadas con MV (k = 6,8-8,0 x 10-2 mmol TEAC / l /mes)

Efecto de diferentes condiciones de tostado sobre el valor nutritivo y la estabilidad oxidativa de aceites de semillas de Brassica napus alto oleico y semillas amarillas

This study was conducted to evaluate the possibility of enhancing the nutritional value and oxidative stability of rapeseed oil obtained from seeds subjected to thermal treatment prior to pressing. The yellowseeded and high-oleic B. napus lines, harvested in Poland, were roasted prior to pressing for 1 h at 100 and 150 °C. This study highlighted how rapeseed breeding lines affect the quality profile of the oils obtained both before and after the roasting process. In principle, the high-oleic B. napus was accompanied by a nearly 2-fold increase in oxidative stability compared to the yellow-seeded B. napus, most likely due to a higher content of oxidation-resistant oleic fatty acids (~74.24% vs. ~60.76%) and a decreased concentration of oxidizable PUFAs (~16.32% vs. ~31.09%). Similar to the case of roasting black-seeded rapeseed, the thermal pre-treatment of yellow-seeded and high-oleic B. napus prior to pressing did not alter the composition of their fatty acids. Based on the results obtained in this study, it can be concluded that roasting seeds prior to pressing does not reduce the amount of tocopherols in the oil; moreover, a slight increase in γ-tocopherol content was observed.Este estudio se realizó para evaluar la posibilidad de aumentar el valor nutritivo y la estabilidad oxidativa del aceite de colza obtenido a partir de semillas sometidas a tratamiento térmico antes del prensado. Las líneas de B. napus sembrados amarillos y alto oleico, cosechadas en Polonia, fueron tostadas antes de ser prensadas durante 1 hora a 100 y 150 °C. Este estudio pone de relieve cómo las líneas de colza mejoradas ven afectado el perfil de calidad de los aceites obtenidos antes y después del proceso de tostado. En principio, el alto oleico B. napus aumenta casi 2 veces la estabilidad a la oxidación en comparación con semilla amarilla B. napus, muy probablemente debido a un mayor contenido de ácido graso oleico resistente a la oxidación (~74,24% vs. ~60,76%) y una concentración menor de PUFAs oxidables (~16,32% frente a ~31,09%). Similar al caso de tostar semillas de colza-negro, las semillas amarillas y las alto oleico de B. napus antes tratadas térmicamente antes del prensado no alteran su composición de ácidos grasos. También Basándonos en los resultados obtenidos en este estudio, se puede concluir que el tostado semillas antes del prensado no reduce la cantidad de tocoferol en aceite; Además, se observó ligero aumento en el contenido de γ-tocoferol

Composición química y resistencia a la oxidación de aceite de colza alto oleico prensado de semillas intactas y descascarilladas pre-tratadas con microondas

The influence of a microwave (MV) pre-treatment (3, 6, 9 min, 800W) on the physicochemical properties of high-oleic rapeseed oil prepared from intact (HORO) and de-hulled seeds (DHORO) was investigated in this study. A control DHORO contained higher levels of total tocopherols and carotenoids, while higher concentrations of total phenolic compounds and chlorophylls were detected in the HORO. The MV pre-treatment caused a decrease in the unsaturated fatty acids content that was more evident for the DHOROs. The microwaving time significantly affected phytochemical contents and the color of both types of oils. A vast increase in canolol concentration was noticeable following 9 min of microwaving, which increased 506- and 155-fold in the HORO and DHORO, respectively. At the same time, the antioxidant capacity of oil produced from MV pre-treated seeds for 9 min was nearly 4 times higher than that of the control oil for both types of oilsEn este estudio se investigó la influencia del pretratamiento con microondas (MV) en las propiedades fisicoquímicas del aceite de colza alto oleico preparado a partir de semillas húmedas (HORO) y descascarilladas (DHORO) (3, 6, 9 min, 800W). El control DHORO contenía un nivel más alto de tocoferoles totales y carotenoides, mientras que se detectó una mayor concentración de compuestos fenólicos totales y clorofilas en el HORO. El pretratamiento de MV provocó una disminución en el contenido de ácidos grasos insaturados que fue más evidente para los DHOROs. El tiempo de microondas afectó significativamente al contenido fitoquímico y al color de ambos tipos de aceites. Se observó un gran aumento de la concentración de canolol después de 9 min de microondas, que aumentó 506 y 155 veces en el HORO y DHORO, respectivamente. Al mismo tiempo, la capacidad antioxidante del aceite producido a partir de semillas pretratadas de MV durante 9 min fue casi 4 veces mayor que la del aceite de control para ambos tipos de aceites

Influencia del tostado de colza descascarillada sobre la composición fisicoquímica y el estado oxidativo del aceite

The effect of roasting time on the contents of bioactive compounds (tocopherols, phytosterols, phenolic compounds), antioxidant capacity and physicochemical properties of rapeseed oil pressed from de-hulled seeds was investigated. The de-hulled seeds were roasted at a temperature of 165 °C for 20, 40, 60, 80, and 100 min. The results of this study show that a roasting pre-treatment led to a gradual increase in canolol content (from 1.34 to 117.33 mg/100 g), total phytosterols (from 573.51 to 609.86 mg/100 g) and total carotenoids (0.82 to 2.41 mg/100 g), while only slight changes in the contents of tocopherols were noted. With the increase in roasting time a gradual increase in oxidative stability (from 4.27 to 6.85 h), and antioxidant capacity, seen mainly in the hydrophilic fraction of oil (from 0.32 to 2.30 mmol TEAC/l) was found. Although roasting resulted in the formation of primary and secondary oxidation products, the quality parameters of oils were within Codex Alimentarius limits.Se estudió el efecto del tiempo de tostado sobre el contenido de compuestos bioactivos (tocoferoles, fitoesteroles, compuestos fenólicos), capacidad antioxidante y propiedades fisicoquímicas del aceite de prensado de semillas descascarilladas de colza. Las semillas descascarilladas se tostaron a una temperatura de 165 ºC durante 20, 40, 60, 80 y 100 min. Los resultados de este estudio muestran que el pretratamiento con tostado condujo a un aumento gradual del contenido de canolol (de 1,34 a 117,33 mg/100 g), fitosteroles totales (de 573,51 a 609,86 mg/100 g) y carotenoides totales (0,82 a 2,41 mg/ 100 g). Sólo se observaron ligeros cambios en el contenido de tocoferoles. Con el incremento del tiempo de tostado se observó un aumento gradual de la estabilidad oxidativa (de 4,27 a 6,85 h) y se encontró capacidad antioxidante, observada principalmente en la fracción hidrofílica de aceite (de 0,32 a 2,30 mmol TEAC/l). Aunque, el tostado produjo formación de productos de oxidación primaria y secundaria, los parámetros de calidad de los aceites estaban dentro de los límites del Codex Alimentarius

Influence of de-hulled rapeseed roasting on the physicochemical composition and oxidative state of oil

The effect of roasting time on the contents of bioactive compounds (tocopherols, phytosterols, phenolic compounds), antioxidant capacity and physicochemical properties of rapeseed oil pressed from de-hulled seeds was investigated. The de-hulled seeds were roasted at a temperature of 165 °C for 20, 40, 60, 80, and 100 min. The results of this study show that a roasting pre-treatment led to a gradual increase in canolol content (from 1.34 to 117.33 mg/100 g), total phytosterols (from 573.51 to 609.86 mg/100 g) and total carotenoids (0.82 to 2.41 mg/100 g), while only slight changes in the contents of tocopherols were noted. With the increase in roasting time a gradual increase in oxidative stability (from 4.27 to 6.85 h), and antioxidant capacity, seen mainly in the hydrophilic fraction of oil (from 0.32 to 2.30 mmol TEAC/l) was found. Although roasting resulted in the formation of primary and secondary oxidation products, the quality parameters of oils were within Codex Alimentarius limits

The effect of microwave pre-treatment of rapeseed on the degradation kinetics of lipophilic bioactive compounds of the oil during storage

This study examined the storage stability of tocochromanols and carotenoids in the oils prepared from microwave pre-treated (MV) rapeseeds (2-10 min, 800W) during storage at 20 °C for 12 months. In line with lipophilic antioxidant degradation throughout the storage period, changes in the antioxidant capacity of the oil were monitored. Microwaving significantly affected the concentration of lipophilic antioxidants in the oil. After 10 min of MV pre-treatment the highest content of total tocochromanols (76.64 mg/100g) was achieved, whereas a maximum carotenoid concentration (861.28 μg/100g) was obtained following 6 min seed MV pre-treatment. The degradation kinetics for the tocochromanols and carotenoids followed a zero-order kinetic model. From the kinetic analysis, it was shown that the degradation rate constant (k) of both tocochromanols and carotenoids decreased with longer seed exposure to MV radiation. The kinetics of antioxidant capacity degradation during the storage of oils followed a zero-order reaction. The rate of antioxidant capacity degradation in the control oil was higher (k=9.1 x 10-2 mmol TEAC/l/month) compared with oils prepared from MV pre-treated seeds (k=6.8-8.0 x 10-2 mmol TEAC/l/month)

Study of the deformability of 5xxx series aluminum alloys with high Mg content in a semi-industrial extrusion process

W pracy przedstawiono wyniki badań procesu wyciskania na gorąco stopów AlMg o wysokich zawartościach Mg; analizę odkształcalności materiału i badania własności wytrzymałościowych wyrobu. Próby wyciskania kształtowników ze stopów aluminium w gatunkach PN-EN 5083 i PN-EN 5019 wykonano na półprzemysłowej prasie hydraulicznej poziomej o nacisku 5 MN, z wykorzystaniem matryc płaskich 2-otworowych. Analizowano parametry procesu wyciskania oraz własności mechaniczne kształtowników wyciskanych ze stopów o rożnej zawartości Mg. Określono maksymalną, dopuszczalną prędkość wypływu metalu z otworu matrycy i graniczne temperatury solidus i likwidus ww. stopów w zależności od zawartości Mg w stopie.This paper presents the results of studies of the hot extrusion process of AlMg aluminum alloys with high Mg content; analysis of material deformability, and tests of product strength properties. Trial extrusions of sections made of aluminum alloy grades PN-EN 5083 and PN-EN 5019 were conducted on a semi-industrial horizontal hydraulic press with a pressing force of 5 MN using 2-hole flat dies. Extrusion process parameters and mechanical properties of sections extruded from alloys of varying Mg content were analyzed. The maximum acceptable rate of metal extrusion from the die hole and limit solidus and liquidus temperatures of the aforementioned alloys were determined depending on the Mg content in the alloy

An Infrared Sensor for Monitoring Meibomian Gland Dysfunction

Meibomian gland dysfunction is one of the most common eye disorders observed in clinical practice. It applies to almost 50% of the population, especially people using contact lenses. It is believed that meibomian gland dysfunction is the most common cause of abnormal stability and integrity of the tear film. Despite this, there is no commercially available equipment for the diagnosis. The article proposes the construction of an optical sensor and a computer system for the rapid, non-invasive diagnosis of meibomian gland dysfunction. The designed hardware and software as well as preliminary results of clinical research are also described