Observer techniques for estimating the state-of-charge and state-of-health of VRLABs for hybrid electric vehicles

The paper describes the application of observer-based state-estimation techniques for the real-time prediction of state-of-charge (SoC) and state-of-health (SoH) of lead-acid cells. Specifically, an approach based on the well-known Kalman filter, is employed, to estimate SoC, and the subsequent use of the EKF to accommodate model non-linearities to predict battery SoH. The underlying dynamic behaviour of each cell is based on a generic Randles' equivalent circuit comprising of two-capacitors (bulk and surface) and three resistors, (terminal, transfer and self-discharging). The presented techniques are shown to correct for offset, drift and long-term state divergence-an unfortunate feature of employing stand-alone models and more traditional coulomb-counting techniques. Measurements using real-time road data are used to compare the performance of conventional integration-based methods for estimating SoC, with those predicted from the presented state estimation schemes. Results show that the proposed methodologies are superior with SoC being estimated to be within 1% of measured. Moreover, by accounting for the nonlinearities present within the dynamic cell model, the application of an EKF is shown to provide verifiable indications of SoH of the cell pack

Human-like Energy Management Based on Deep Reinforcement Learning and Historical Driving Experiences

Development of hybrid electric vehicles depends on an advanced and efficient energy management strategy (EMS). With online and real-time requirements in mind, this article presents a human-like energy management framework for hybrid electric vehicles according to deep reinforcement learning methods and collected historical driving data. The hybrid powertrain studied has a series-parallel topology, and its control-oriented modeling is founded first. Then, the distinctive deep reinforcement learning (DRL) algorithm, named deep deterministic policy gradient (DDPG), is introduced. To enhance the derived power split controls in the DRL framework, the global optimal control trajectories obtained from dynamic programming (DP) are regarded as expert knowledge to train the DDPG model. This operation guarantees the optimality of the proposed control architecture. Moreover, the collected historical driving data based on experienced drivers are employed to replace the DP-based controls, and thus construct the human-like EMSs. Finally, different categories of experiments are executed to estimate the optimality and adaptability of the proposed human-like EMS. Improvements in fuel economy and convergence rate indicate the effectiveness of the constructed control structure.Comment: 8 pages, 10 figure

Optimisation-based Approaches for Evaluating the Aggregation of EVs and PVs in Unbalanced Low-Voltage Networks

214 p.In the near future, it is expected that the distribution system operators face different technical challenges derived from the massification of electric mobility and renewable energy sources in the low voltage networks. The purpose of this thesis is to define different smart coordination strategies among different agents involved in the low voltage networks such as the distribution system operator, the aggregators and the end-users when significant penetration levels of these resources are adopted. New models for representing the uncertainty of the photovoltaic output power and the connection of the electric vehicles are introduced. A new energy boundary model for representing the flexibility of electric vehicles is also proposed. In combination with the above models, four optimisation models were proposed as coordination strategies into three different approaches: individual, population, and hybrid. The first model was defined at the aggregator level, whereas the other models were proposed at the distribution system operator level. Complementary experimental cases about the proposed optimisation model in the individual-based approach and the quadratic formulation in the hybrid approach for the PV power curtailment were carried out to test its response in real-time. Simulations results demonstrated that the proposed coordination strategies could effectively manage critical insertion levels of electric vehicles and photovoltaic units in unbalanced low voltage networks

Series Hybrid Electric Vehicle Simultaneous Energy Management and Driving Speed Optimization

The energy management (EM) and driving speed co-optimization of a series hybrid electric vehicle (S-HEV) for minimizing fuel consumption is addressed in this article on the basis of a suitably modeled series powertrain architecture. The paper proposes a novel strategy that finds the optimal driving speed simultaneously with the energy source power split for the drive mission specified in terms of the road geometry and travel time. Such a combined optimization task is formulated as an optimal control problem that is solved by an indirect optimal control method, based on Pontryagin’s minimum principle. The optimization scheme is tested under a rural drive mission by extensive comparisons with conventional methods that deal with either speed optimization only or EM strategies with given driving cycles. The comparative results show the superior performance of the proposed method and provide further insight into efficient driving

Real-time state of charge estimation of electrochemical model for lithium-ion battery

This paper proposes the real-time Kalman filter based observer for Lithium-ion concentration estimation for the electrochemical battery model. Since the computation limitation of real-time battery management system (BMS) micro-processor, the battery model which is utilized in observer has been further simplified. In this paper, the Kalman filter based observer is applied on a reduced order model of single particle model to reduce computational burden for real-time applications. Both solid phase surface lithium concentration and battery state of charge (SoC) can be estimated with real-time capability. Software simulation results and the availability comparison of observers in different Hardware-in- the-loop simulation setups demonstrate the performance of the proposed method in state estimation and real-time application

The Jet Propulsion Laboratory Electric and Hybrid Vehicle System Research and Development Project, 1977-1984: A Review

The JPL Electric and Hybrid Vehicle System Research and Development Project was established in the spring of 1977. Originally administered by the Energy Research and Development Administration (ERDA) and later by the Electric and Hybrid Vehicle Division of the U.S. Department of Energy (DOE), the overall Program objective was to decrease this nation's dependence on foreign petroleum sources by developing the technologies and incentives necessary to bring electric and hybrid vehicles successfully into the marketplace. The ERDA/DOE Program structure was divided into two major elements: (1) technology research and system development and (2) field demonstration and market development. The Jet Propulsion Laboratory (JPL) has been one of several field centers supporting the former Program element. In that capacity, the specific historical areas of responsibility have been: (1) Vehicle system developments (2) System integration and test (3) Supporting subsystem development (4) System assessments (5) Simulation tool development

Supervisory Control Optimization for a Series Hybrid Electric Vehicle with Consideration of Battery Thermal Management and Aging

This dissertation integrates battery thermal management and aging into the supervisory control optimization for a heavy-duty series hybrid electric vehicle (HEV). The framework for multi-objective optimization relies on novel implementation of the Dynamic Programing algorithm, and predictive models of critical phenomena. Electrochemistry based battery aging model is integrated into the framework to assesses the battery aging rate by considering instantaneous lithium ion (Li+) surface concentration rather than average concentration. This creates a large state-action space. Therefore, the computational effort required to solve a Deterministic or Stochastic Dynamic Programming becomes prohibitively intense, and a neuro-dynamic programming approach is proposed to remove the ‘curse of dimensionality’ in classical dynamic programming. First, unified simulation framework is developed for in-depth studies of series HEV system. The integration of a refrigerant system model enables prediction of energy use for cooling the battery pack. Side reaction, electrolyte decomposition, is considered as the main aging mechanism of LiFePO4/Graphite battery, and an electrochemical model is integrated to predict side reaction rate and the resulting fading of capacity and power. An approximate analytical solution is used to solve the partial difference equations (PDEs) for Li+ diffusion. Comparing with finite difference method, it largely reduces the number of states with only a slight penalty on prediction accuracy. This improves computational efficiency, and enables inclusion of the electrochemistry based aging model in the power management optimization framework. Next, a stochastic dynamic programming (SDP) approach is applied to the optimization of supervisory control. Auxiliary cooling power is included in addition to vehicle propulsion. Two objectives, fuel economy and battery life, are optimized by weighted sum method. To reduce the computation load, a simplified battery aging model coupled with equivalent circuit model is used in SDP optimization; Li+ diffusion dynamics are disregarded, and surface concentration is represented by the average concentration. This reduces the system state number to four with two control inputs. A real-time implementable strategy is generated and embedded into the supervisory controller. The result shows that SDP strategy can improve fuel economy and battery life simultaneously, comparing with Thermostatic SOC strategy. Further, the tradeoff between fuel consumption and active Li+ loss is studied under different battery temperature. Finally, the accuracy of battery aging model for optimization is improved by adding Li+ diffusion dynamics. This increases the number of states and brings challenges to classical dynamic programming algorithms. Hence, a neuro-dynamic programming (NDP) approach is proposed for the problem with large state-action space. It combines the idea of functional approximation and temporal difference learning with dynamic programming; in that case the computation load increases linearly with the number of parameters in the approximate function, rather than exponentially with state space. The result shows that ability of NDP to solve the complex control optimization problem reliably and efficiently. The battery-aging conscientious strategy generated by NDP optimization framework further improves battery life by 3.8% without penalty on fuel economy, compared to SDP strategy. Improvements of battery life compared to the heuristic strategy are much larger, on the order of 65%. This leads to progressively larger fuel economy gains over time